About this Journal Submit a Manuscript Table of Contents
ISRN Chemical Engineering
Volume 2012 (2012), Article ID 921873, 6 pages
http://dx.doi.org/10.5402/2012/921873
Research Article

Oxalic Acid Regeneration of Ceramic Filter Medium Used in the Dewatering of Iron Ore

1LUT Chemistry, Lappeenranta University of Technology, Skinnarilankatu 34, 53850 Lappeenranta, Finland
2Laboratory of Inorganic Materials, Tallinn University of Technology, Ehitajate Tee 5, 19086 Tallinn, Estonia
3Outotec (Filters) Oy, Urusvuorenkatu 5, 20630 Turku, Finland

Received 17 September 2012; Accepted 23 October 2012

Academic Editors: J. Lobato and A. Szymczyk

Copyright © 2012 Riina Salmimies et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Abstract

The regeneration of the ceramic filter medium in the dewatering of iron ore enables the use of the medium for much longer periods in comparison to traditional filter cloths. The regeneration is commonly a combination of several techniques, of which one is the acid washing of the medium. Despite being effective against iron oxides, the phenomena related to the acid washing of the ceramic filter medium with oxalic acid have so far been less extensively published. The aim of this study was to investigate the dissolution of iron oxide particles from the surface of the filter medium and the consequent changes in the performance and in the structure of the medium. The dissolution of the particles was found to exhibit some kind of a steady state dependent on temperature but not so much on the acid concentration. Changes in permeability as well as in pore size were found to take place even after the dissolution of the particles had ceased.