Characterization of a Methanogenic Community within an Algal Fed Anaerobic Digester

Ellis, Joshua T.; Tramp, Cody; Sims, Ronald C.; Miller, Charles D.

doi:https://doi.org/10.5402/2012/753892

International Scholarly Research Notices

On this page

Abstract Introduction Methods Results and Discussion Conclusions Acknowledgments References Copyright Related Articles

Research Article | Open Access

Volume 2012 | Article ID 753892 | https://doi.org/10.5402/2012/753892

Characterization of a Methanogenic Community within an Algal Fed Anaerobic Digester

Joshua T. Ellis,¹Cody Tramp,¹Ronald C. Sims,¹and Charles D. Miller¹

Academic Editor: J. Maupin-Furlow, T. P. West

Received13 Mar 2012

Accepted24 Apr 2012

Published21 Jun 2012

Abstract

The microbial diversity and metabolic potential of a methanogenic consortium residing in a 3785-liter anaerobic digester, fed with wastewater algae, was analyzed using 454 pyrosequencing technology. DNA was extracted from anaerobic sludge material and used in metagenomic analysis through PCR amplification of the methyl-coenzyme M reductase α subunit (mcrA) gene using primer sets ML, MCR, and ME. The majority of annotated mcrA sequences were assigned taxonomically to the genera Methanosaeta in the order Methanosarcinales. Methanogens from the genus Methanosaeta are obligate acetotrophs, suggesting this genus plays a dominant role in methane production from the analyzed fermentation sample. Numerous analyzed sequences within the algae fed anaerobic digester were unclassified and could not be assigned taxonomically. Relative amplicon frequencies were determined for each primer set to determine the utility of each in pyrosequencing. Primer sets ML and MCR performed better quantitatively (representing the large majority of analyzed sequences) than primer set ME. However, each of these primer sets was shown to provide a quantitatively unique community structure, and thus they are of equal importance in mcrA metagenomic analysis.

1. Introduction

Global energy requirements are heavily dependent on fossil fuels such as oil, coal, and natural gas. With the anticipation of fossil fuels being exhausted in the future, novel strategies need to be discovered for alternative energy generation. Of increasing importance is biogas production from renewable biomass feedstocks. The Logan City Wastewater Lagoon System (LCWLS) is an open-pond wastewater treatment facility that supports the growth of microbial communities that work symbiotically to metabolize and stabilize organic matter [1]. The microbial community present within the anaerobic sludge sediment has been used as inoculum for pilot scale anaerobic digestion processes where algal biomass is used as substrate. Algal biomass that occurs naturally in the LCWLS has been effectively harvested from the wastewater effluent and used for methane generation. Algae have been identified as a promising renewable energy feedstock due to their effective conversion of solar energy to biomass [2], which occurs naturally in this open-pond wastewater treatment facility. Anaerobically digested algal biomass generated from this system provides an appropriate technological approach to algal biofuels [3]. To date, methanogenic Archaea community-based studies on algal fed anaerobic digesters inoculated with wastewater sludge sediment have not been reported in the referred literature.

Anaerobic digestion is a series of processes in which microorganisms metabolize and stabilize biodegradable material in anaerobic conditions. These microbial interactions are considered to be symbiotic or even commensalistic interactions involving hydrolysis, acidogenesis, acetogenesis, and methanogenesis [1]. The process of anaerobic digestion is used for industrial or domestic purposes to manage waste and/or to release energy in the form of methane gas [4]. Methane is generated through anaerobic fermentation of low-molecular-weight carbon compounds through the process of methanogenesis [5]. Methanogenic Archaea play an essential role in the recycling of carbon in the biosphere and are estimated to produce approximately one billion tons of methane annually in anoxic conditions [6, 7], thus driving the motivation to employ this unique methanogenic physiotype at industrial scales. Methane derived from anaerobic treatment of organic wastes has a great potential to be an alternative fuel source and may stimulate independent and domestic energy economies [8, 9].

Diverse consortiums of methanogenic Archaea produce methane in the anaerobic sediments of the Logan Lagoons. These archaeal communities have not been studied to date, thus providing an uncultured archaeal community for study. There is increasing interest in analyzing the organization and function of biogas producing ecosystems, particularly since the relationships among biogas producing microbial populations are not well understood [5].

Methanogenic Archaea is one of the largest and most phylogenetically diverse groups of microbes in the Archaea domain. Presently, six different orders of methanogens have been recognized: Methanosarciniales, Methanomicrobiales, Methanococcales, Methanobacterales, Methanocellales, and Methanopyrales [10, 11]. These microbes have evolved pathways for the metabolism of simple carbon substrates, such as acetate, carbon dioxide, formate, and methanol. There are generally three methanogenic pathways described throughout the literature. These pathways, shown in Figure 1, are as follows: (1) the CO₂ reduction pathway involves the reduction of CO₂ to CH₄ with hydrogen gas as electron donor (hydrogenotrophic) and/or formate; (2) the methylotrophic pathway involves the disproportionation of methylated compounds, such as methanol and methylamines to CO₂ and CH₄; (3) the acetoclastic pathway involves the dismutation of acetate to CO₂ and CH₄ [12–15].

The methyl-coenzyme M reductase (MCR) is a holoenzyme that is composed of two alpha (mcrA), two beta (mcrB), and two gamma (mcrG) subunits, encoded by the mcrBDCGA operon. It catalyzes heterodisulfide formation and subsequent release of methane by combing the hydrogen donor coenzyme B and methyl donor coenzyme M [16, 17]. This enzyme is commonly referred to as isoenzyme MCRI. Additionally, members of the orders Methanobacteriales and Methanococcales carry the isoenzyme MCRII, coded by the mrtBDGA operon [18, 19]. MCR subunits are phylogenetically conserved throughout all methanogens and are necessary for the production of cellular energy. This protein is not found in bacteria, eukarya, or other Archaea [17]. Additionally, lateral gene transfer of MCR genes throughout Archaea species has not been observed [16], thus the MCR operon, and particularly the mcrA gene, has been widely used as an explicit marker for the detection of methanogenic diversity within a particular ecological niche [5, 11, 19–22].

To date, there is no refereed literature regarding methanogenic communities inhabiting algal fed anaerobic digesters. However, there are several descriptions of biogas production using algal biomass as substrate [2, 23–27]; yet, no information on methanogenic consortiums in these systems exists to date. To advance the understanding of methanogenic consortiums inhabiting an algal fed anaerobic digester inoculated with anaerobic sludge material from the LCWLS, metagenomic analysis of the methyl-coenzyme M reductase alpha subunit (mcrA) gene was carried out using 454 pyrosequencing. Pyrosequencing technology has provided the ability to efficiently sequence target genes from environmental samples, while overriding cloning biases and sequence limitation from traditional clone libraries [5].

Three primer sets, ML, MCR, and ME (Table 1), have been described previously for comparing methanogenic Archaea communities in mcrA clone libraries [11, 19], but have not been reported to be incorporated into high-throughput 454 pyrosequencing in combination to determine the feasibility of these primers in methanogenic Archaea metagenomic analysis. In order to accurately demonstrate the diversity of an environmental sample, pyrosequencing technologies can be employed. Pyrosequencing allows investigators to examine thousands of sequences, while allowing the discovery of rare organisms among thousands of dominant species, both of which are extremely difficult in clone library methodologies. Recently, pyrosequencing of a biogas microbial community within a maize silage, green rye, and liquid manure fed anaerobic digester using primer sets ML and ME described the taxonomic order Methanomicrobiales and, more particularly, Methanoculleus bourgensis, as being the dominant species within the analyzed fermentation sample [5].

This study focuses on the structure and characterized diversity of a methanogenic consortium and its metabolic potential residing in biosolids sediment within a 3785-liter algal fed anaerobic digester, with emphasis on the mcrA gene using and analyzing primer sets ML, MCR, and ME.

2. Methods

2.1. Sampling Site and Characteristics

Sludge material from a 3785-Liter algal fed anaerobic digester was collected from a sampling port on the bottom of the digester and immediately stored under N₂. This anaerobic digester was operated at 37°C, had a hydraulic retention time of 20 days, and operated in fed batch mode. Algae substrate was harvested from lagoon wastewater effluent using a dissolved air floatation unit, with an average concentration of 10 g L⁻¹.

2.2. Nucleic Acid Extraction and Amplification of mcrA Genes

Total community DNA was extracted from 250 mg of sludge sediment using the PowerSoil DNA Isolation Kit (MO BIO Labs. Inc., Solana Beach, CA). Samples were stored under N₂ for no longer than 30 minutes prior to DNA isolation. The degenerate archaeal primers, ML, MCR, and ME [11, 21, 28], were used to PCR-amplify mcrA gene fragments from purified DNA (Table 1). These primer sets have partially overlapping target regions as shown in Figure 2. Primers sequences were as follows (5′-3′): MLf: GGTGGTGTMGGATTCACACARTAYGCWACAGC, MLr: TTCATTGCRTAGTTWGGRTAGTT [19, 29], and previously described as primer Luton mcrA [11, 21]; MCRf: TAYGAYCARA THTGGYT, MCRr: ACRTTCATNGCRTARTT [11, 19]; MEf: GCMATGCARAT HGGWATG TC; MEr: TCATKGCRTAGTTDGGRTAGT [11, 19, 20, 28]. Appropriate tags and multiplex identifiers were used for each primer set for downstream 454 pyrosequencing. The PCR mixture contained 1 μL of DNA (25 ng final concentration for reactions concerning primer ML and MCR, and 40 ng concerning primer ME), 1 μL of each primer (25 μM), 5 μL of 10x PCR buffer, 1 μL of bovine serum albumin (15 mg/mL), 5 μL of deoxynucleoside triphosphates (2 mM each of dATP, dTTP, dGTP, and dCTP), 0.5 μL Taq DNA polymerase (5U/μL), and 2.5 μL MgCl₂(25 mM) in a final reaction volume of 50 μL. Amplification was carried out as follows: initial denaturation for 2 min at 95°C, 35 cycles of 95°C for 1 min, annealing at 58°C (ML), 50°C (MCR), or 56°C (ME) for 1 min, and 1.5 min at 72°C, with a final extension for 12 min at 72°C. PCR products were checked for positive amplification and correct amplicon size by agarose gel electrophoresis. Positive amplicons were purified using the PCR purification kit (Qiagen Inc., Valencia, CA), as indicated by the manufacturer. Target PCR amplicons were of sizes 470 bp, 500 bp, and 760 bp for primer sets ML, MCR, and ME, respectively, (Table 1).

2.3. High-Throughput Sequencing and BLASTn Analysis of mcrA Metagenome Reads

Sequencing runs were performed on mcrA libraries prepared from total sludge community DNA using the Roche Genome Sequencer (GS) FLX System. Samples were pooled together and incorporated into two wells of the 454 plate. The sequencing data output file was analyzed using a program written in Visual Basic.NET. This program converted the .fna data file into standard FASTA format. Sequences were sorted by primer ID tags, ID tags were removed, and sequences were filtered by length. Only sequences over 100 bp in size were analyzed by BLASTn; sequences shorter than 100 bp were mainly primer dimer reads and were thus redundant in this analysis. Identical sequences were combined, and all sequences were named with the primer set code, an ID number, and the number of combined sequences it represented. BLASTn analysis was conducted using the “Nucleotide collection (nr/nt)” database and allowing 20,000 max target sequences. For each sequence, a list of top BLAST hits was compiled, filtered for alignments of at least 50 bp and E-values smaller than 1. Uncultured clones were removed from the list of top hits to allow us to derive information on the functionality of the system in the sense of metabolic potential and community structures based on characterized physiotypes. For each sequence, the BLAST hit with the highest BLAST score was selected as the match’s species. Sequence similarities were all greater than 97% identical to the species identified. A total of each species’ hit count was then generated, taking into account the number of identical sequences that were combined into each analyzed sequence prior to BLASTn analysis.

2.4. Phylogenetic Analysis

Nucleotide sequences for mcrA genes were pooled together for each primer set and used to determine the phylogenetic diversity. Phylogenetic analysis of mcrA sequences was accomplished by using the MEGA 5.01, Molecular Evolutionary Genetic Analysis web-based software package [31, 33]. Alignment files were generated using ClustalW, a function within MEGA. The evolutionary history was inferred by using the Maximum Likelihood method based on the Tamura-Nei model [33]. Phylogenetic trees with the highest log likelihood are shown. The percentage of trees in which the associated taxa clustered together is shown next to the branches. Initial tree(s) for the heuristic search were obtained automatically as follows. When the number of common sites was less than 100, or less than one-fourth of the total number of sites, the maximum parsimony method was used; otherwise BIONJ method with MCL distance matrix was used. The tree is drawn to scale, with branch lengths measured in the number of substitutions per site [31, 33].

3. Results and Discussion

3.1. Methanogenic Community Structure Analysis Based on High-Throughput 454 Sequencing of Methyl-Coenzyme M Reductase Genes

Community DNA extracted from a fermentation sample was evaluated using three mcrA-specific primer sets (ML, MCR, and ME). This study provided useful information on the effectiveness of these primers in metagenomic analysis. Additionally, phylogenetic analysis as well as the metabolic potential of the anaerobic system was established from 454 pyrosequencing data. Purified DNA was used as template for PCR-based amplification of community mcrA genes. Positive amplicons were employed in high-throughput 454 pyrosequencing and analyzed as described above. Pyrosequencing output files described a total of 57,758 total sequences. 454 sequences less than 100 bps (shown to be primer dimer formation) were removed from the analysis to prevent redundancy. Analysis of mcrA gene sequences using the BLAST-nr database (E-value < 1) designated 1,634 sequences to match known or characterized methanogens, all of which had sequence similarity of at least 97% and E-value < 1. This was performed to allow relevant information to be derived on the functionality of biogas production from the algae fed anaerobic digester. After filtering data sets as described above, primer ML had a total of 382 mcrA sequences, primer MCR had a total of 1,080 sequences, and primer ME had a total of 172 mcrA sequences. A total of 1,634 methyl-coenzyme M reductase genes was incorporated into the final analysis. Sequence data from each primer set and pooled data were then organized taxonomically on order (Figure 3), genus, and species (Table 2). About 14% of analyzed sequences could not be assigned taxonomically, described as no significant similarity found (Table 2), indicating that many of the methanogens within the algal fed anaerobic digester are unclassified or novel. Only 1,634 sequences were analyzed in this study due to the removal of many thousands of uncultured or uncharacterized clone sequences which currently do not provide any useful information on the functionality of the system, however, indicate that isolation and characterization of these methanogens would provide a more comprehensive understanding of the system.

(a)

(b)

(c)

(d)

3.2. mcrA Primer Analysis

The molecular approach described above has identified various unique sequences among primer sets ML, MCR, and ME. Despite multiple attempts to optimize PCR conditions, the low efficiency of primer set ME gave poor yields of PCR products compared to primer sets ML and MCR, as determined by analysis of agarose gel band intensity and spectrophotometric measurements of purified PCR products. The ME primer set may not have been ideal for proper annealing with the large majority of methanogenic mcrA genes in our community DNA samples (as shown in Figure 2). The ME primer set has been described to capture a wide range of methanogens, but our community composition was strongly dominated by members of the order Methanosarcinales, in which primer set ME has shown difficulties in amplifying [34]. However, all primer sets with 454 tags were able to positively amplify mcrA genes within the representative sample for downstream pyrosequencing.

Analysis of the community composition depicts molecular bias towards amplification of mcrA gene fragments, which frequently occurs with PCR-based methods. The utilization of degenerate primers (Table 1) targeting a functional gene is subject to molecular bias due to the degeneracy of the genetic code [11]. The vast majority of the species discovered using primer sets ML and MCR were Methanosaeta concilii; however no hits on these genera were observed using primer set ME. Figure 2 provides additional evidence as MEf did not have ample complementary base pairing, as shown when analyzing Table 1 and Figure 2. The Methanogenic community sets based taxonomically on order represent the molecular bias described, particularly between primer sets ML and MCR compared to primer set ME (Figure 3). Additionally, greater methanogenic diversity in our metagenomic library using primers ML and MCR was observed. The metagenomic library constructed from the ME primers had a reduced methanogenic diversity compared to the other primer sets used in our analysis. These data concur with preliminary work done in our research group where a mcrA clone library was constructed using the same primer sets (data not shown). Additionally, this trend is somewhat consistent throughout the literature where the ME primer set provides noticeably less diversity in the context of mcrA libraries [11, 19], but is still valuable in identifying unique community structures.

3.3. Phylogenetic Analysis of the Algal Fed Sludge Metagenome

Metagenomics has provided more accurate estimations of microbial diversity within environmental samples compared to clone libraries, where multiple biases exist along with sequencing limitations. Additionally, metagenomics is aimed at obtaining an unbiased view of community consortiums within a particular environment [5]. Although an abundance of short amplicon sequences occur in pyrosequencing, the ability to discover the presence of a species that is substantially less abundant than others within a microbial consortium is demonstrated. The sensitivity of pyrosequencing has allowed several organisms that were only present once out of 1,634 characterized sequences to be identified, whereas the probability of locating these rare species amongst a consortium of microbes using clone libraries would be very low.

The phylogeny of methanogenic Archaea from primer sets ML, MCR, and ME is depicted in Figures 4, 5, and 6, respectively. The vast majority of organisms displayed in the phylogenetic tree from Figure 7 were from ML and MCR data sets. This is consistent with the analysis from Figure 3 in that the relative amplicon frequencies from primer ML, MCR, and the pooled data represent methanogens from the order Methanosarcinales. Primer set ME did not generate any hits from the genera Methanosaeta, which represented 71% of the total sequences. However, this primer depicted novel microbes that were not represented with the other primers. Juottonen et al., 2006 [19] described faults with primer ME in amplifying members of the order Methanosarcinales, concurring with our overall analysis of primer ME and its output data. These phylogenetic trees which comprise only characterized methanogens are to validate or derive relevant information on the functionality of the anaerobic system. Again, it is important to consider that there were many uncharacterized or uncultured clone methanogen sequences within this system; however uncharacterized clone sequences do not provide significant data on existing functionality.

Figure 4

Phylogenetic analysis of mcrA sequences developed from primer ML. Phylogenetic tree was constructed using MEGA 5.01 Molecular Evolutionary Genetic Analysis web-based software package [31, 32]. This phylogenetic tree was generated using maximum likelihood analysis with 1000 bootstraps. Numbers at the nodes represent bootstrap values, with only values above 50 shown. Scale bar corresponds to 0.2 substitutions per nucleotide position. Accession numbers are shown in parenthesis. The number following the accession number represents the number of hits for that organism.

Figure 5

Phylogenetic analysis of mcrA sequences acquired from primer MCR. Phylogenetic tree was constructed using MEGA 5.01 Molecular Evolutionary Genetic Analysis web-based software package [31, 32]. This phylogenetic tree was generated using maximum likelihood analysis with 1000 bootstraps. Numbers at the nodes represent bootstrap values, with only values above 50 shown. Scale bar corresponds to 0.2 substitutions per nucleotide position. Accession numbers are shown in parenthesis. The number following the accession number represents the number of hits for that organism.

Figure 6

Phylogenetic analysis of mcrA sequences from primer ME. Phylogenetic tree was constructed using MEGA 5.01 Molecular Evolutionary Genetic Analysis web-based software package [31, 32]. This phylogenetic tree was generated using maximum likelihood analysis with 1000 bootstraps. Numbers at the nodes represent bootstrap values, with only values above 50 shown. Scale bar corresponds to 0.1 substitutions per nucleotide position. Accession numbers are shown in parenthesis. The number following the accession number represents the number of hits for that organism.

Figure 7

Phylogenetic analysis of mcrA sequences from pooled data sets from primers ML, MCR, and ME. Phylogenetic tree was constructed using MEGA 5.01 Molecular Evolutionary Genetic Analysis web-based software package [31, 32]. This phylogenetic tree was generated using maximum likelihood analysis with 1000 bootstraps. Numbers at the nodes represent bootstrap values, with only values above 50 shown. Scale bar corresponds to 0.1 substitutions per nucleotide position. Accession numbers are shown in parenthesis. The number following the accession number represents the number of hits for that organism.

Analysis of mcrA sequences from the algal fed anaerobic digester revealed a broad spectrum of methanogenic microbes. This phylogenetic analysis based on pyrosequencing provided adequate insight into the phylogenetic structure of our system since phylogenetics depicts evolutionary relationships and distances between given genetic fragments [5]. Descriptions of biogas production communities have been established using high-throughput 454 sequencing technologies [5, 35]. Kröber et al., 2009 [5] describe the taxonomic order Methanomicrobiales and, more particularly, Methanoculleus bourgensis, as being the dominant speices within a maize silage, green rye, and liquid manure fed anaerobic digester using primer sets ML and ME. Using primer sets ML, MCR, and ME, we have shown our algal fed anaerobic digester to be highly dominated by the order Methanosarcinales and the obligate acetoclastic genera Methanosaeta. Our phylogenetic relationship in this study would has been significantly skewed if primer set MCR was missing from the study.

3.4. Metabolic Potential of the Algal Fed Sludge Metagenome

Approximately two-thirds of the methane produced in the biosphere is derived from the acetoclastic pathway [34]. Only two genera of methanogenic Archaea, Methanosaeta and Methanosarcina, have been isolated and identified as utilizing acetate for methanogenesis [34]. Approximately 74% percent of our pooled 454 data was dominated by the order Methanosarcinales (Figure 3), including the genera Methanosarcina and the highly dominant genera Methanosaeta. Methanosaeta are considered obligate acetotrophs, in that they solely use acetate for methanogenesis [34]. The genera Methanosaeta greatly dominated the methanogenic diversity suggesting that our particular mesophilic system may have a low concentration of acetate, favoring Methanosaeta spp., which have been recognized as having a subordinate threshold for acetate compared to other acetotrophs associated with the family Methanosarcinaceae [36]. Methanosarcina mazei are capable of producing methane through all three pathways described (Table 2). However, only some strains of this genus can utilize H₂/CO₂ as substrates from methanogenesis [13]. Methanosarcina thermophila can utilize the acetoclastic and the methylotrophic pathways for methanogenesis [13, 36] (Table 2).

Members of the order Methanobacteriales, and particularly those belonging to the genera Methanobacterium, all use the CO₂ reduction pathway with H₂ as electron donor for methanogenesis [37]. Some species of this genus such as M. formicicum and M. palustre can also reduce CO₂ to methane using formate as the electron donor. Methanothermobacter thermautotrophicus can also drive methanogenesis by utilizing the CO₂ reduction pathway with H₂ and/or formate as electron donor [13]. Several mrtA genes were detected from organisms M. formicicum S1 and M. uliginosum DSM 2956 using primers ML and MCR (Table 2). This gene is said to be predominately expressed when the H₂ supply is not growth rate limiting, whereas mcrA would be formed when availability of H₂ is limited. When H₂ supplies are not limited, the MCR reaction may be the rate-limiting step in the methanogenesis pathway, thus it would be physiologically relevant to synthesize an enzyme with a higher [18].

From the order Methanomicrobiales, organisms Methanoculleus palmolei, Methanoculleus marisnigri, Methanoculleus thermophiles, Methanoculleus chikugoensis [13, 38], Methanogenium organophilum [13], Methanolinea tarda [39], Methanoregula formicicum [40], Methanospirillum lacunae, and Methanospirillum hungatei [13, 41], all of which are present in our anaerobic digester, are all capable of utilizing the CO₂ reduction pathway with either H₂/CO₂, or formate as substrates. M. palmolei and M. chikugoensis can also utilize the methylotrophic pathway for methanogenesis by metabolizing secondary alcohols [38] (Table 2).

Of the total 1,634 methyl-coenzyme M reductase sequences analyzed, approximately 74% of the assigned methanogens could utilize the acetoclastic pathway, due to the high abundance of Methanosaeta. About 30% of the assigned methanogens were hydrogenotrophic, and 17% of the total methanogens could also reduce CO₂ to CH₄ with formate as the electron donor. In addition, about 56% of those methanogens that were hydrogenotrophic could reduce CO₂ to CH₄ with formate as the electron donor. Only about 4% of the total methanogens were methylotrophic. These results suggest that species relating to the genus Methanosaeta obligate acetotrophs, and members of the order Methanosarcinales play a dominant role in the production of CH₄ in the algal fed anaerobic digester.

4. Conclusions

A comprehensive investigation of the phylogeny and metabolic potential of methanogenic Archaea residing in an algal fed anaerobic digester was accomplished using three different mcrA primer sets. The mcrA gene encodes the α-subunit of methyl-coenzyme M reductase and is widely used as a phylogenetic marker for characterization of methanogenic communities because it is conserved throughout all methanogenic Archaea [5, 21]. Although primer set ME exhibited deficiencies in amplifying mcrA genes from Methanosarcinales and depicted less methanogenic diversity compared to primer sets ML and MCR, it was a valuable tool in this analysis as it identified marginal methanogens that would have been absent otherwise. Juottonen et al., 2006 [19] described that the use of these three primer sets provided a quantitatively unique community structure through clone libraries, and they were confirmed to do so as well using pyrosequencing technology. Several hits only appeared once out of all the analyzed sequences, showing the sensitivity of high-throughput 454 sequencing technologies over standard clone libraries. Accordingly, the use of these three primer sets provided a comprehensive analysis of the methanogenic Archaea residing in an algal fed anaerobic digester, and these sets were found to all be of equal significance in mcrA metagenomic analysis. A large portion of the analyzed sequences could not be assigned taxonomically, signifying that many of the methanogens within the analyzed fermentation sample are unclassified or novel. Phylogenetic analysis of this algal fed anaerobic digester indicates a broad range of methanogens from the orders Methanobacteriales, Methanomicrobiales, and Methanosarcinales, with the latter being the overall dominant order. Additionally, these results suggest that species relating to the genus Methanosaeta, members of the order Methanosarcinales, which are obligate acetotrophs, play a dominant role in methanogenesis in the analyzed fermentation sample.

Acknowledgments

The authors thank the US Department of Energy (DOE), the Utah Science Technology and Research initiative (USTAR), and the USU Bioenergy program for financial support. They also thank the Center for Integrated BioSystems (CIB) at Utah State University for their support on sequencing. The authors also thank the City of Logan Environmental Department for providing access and samples from the anaerobic digester. And finally, they thank Neal Hengge for his research efforts as an undergraduate research assistant.

References

S. G. Shin, C. Lee, K. Hwang, J. H. Ahn, and S. Hwang, “Use of order-specific primers to investigate the methanogenic diversity in acetate enrichment system,” Journal of Industrial Microbiology and Biotechnology, vol. 35, no. 11, pp. 1345–1352, 2008.
View at: Publisher Site | Google Scholar
B. Sialve, N. Bernet, and O. Bernard, “Anaerobic digestion of microalgae as a necessary step to make microalgal biodiesel sustainable,” Biotechnology Advances, vol. 27, no. 4, pp. 409–416, 2009.
View at: Publisher Site | Google Scholar
P. E. Wiley, J. E. Campbell, and B. McKuin, “Production of biodiesel and biogas from algae: a review of process train options,” Water Environment Research, vol. 83, no. 4, pp. 326–338, 2011.
View at: Publisher Site | Google Scholar
S. Zeng, X. Yuan, X. Shi, and Y. Qiu, “Effect of inoculum/substrate ratio on methane yield and orthophosphate release from anaerobic digestion of Microcystis spp.,” Journal of Hazardous Materials, vol. 178, no. 1–3, pp. 89–93, 2010.
View at: Publisher Site | Google Scholar
M. Kröber, T. Bekel, N. N. Diaz et al., “Phylogenetic characterization of a biogas plant microbial community integrating clone library 16S-rDNA sequences and metagenome sequence data obtained by 454-pyrosequencing,” Journal of Biotechnology, vol. 142, no. 1, pp. 38–49, 2009.
View at: Publisher Site | Google Scholar
R. C. Kunz, Y. C. Horng, and S. W. Ragsdale, “Spectroscopic and kinetic studies of the reaction of bromopropanesulfonate with methyl-coenzyme M reductase,” Journal of Biological Chemistry, vol. 281, no. 45, pp. 34663–34676, 2006.
View at: Publisher Site | Google Scholar
R. K. Thauer, A. K. Kaster, H. Seedorf, W. Buckel, and R. Hedderich, “Methanogenic archaea: ecologically relevant differences in energy conservation,” Nature Reviews Microbiology, vol. 6, no. 8, pp. 579–591, 2008.
View at: Publisher Site | Google Scholar
D. Pimentel, A. Marklein, M. A. Toth et al., “Food versus biofuels: environmental and economic costs,” Human Ecology, vol. 37, no. 1, pp. 1–12, 2009.
View at: Publisher Site | Google Scholar
M. Tabatabaei, R. A. Rahim, N. Abdullah et al., “Importance of the methanogenic archaea populations in anaerobic wastewater treatments,” Process Biochemistry, vol. 45, no. 8, pp. 1214–1225, 2010.
View at: Publisher Site | Google Scholar
C. Erkel, D. Kemnitz, M. Kube et al., “Retrieval of first genome data for rice cluster I methanogens by a combination of cultivation and molecular techniques,” FEMS Microbiology Ecology, vol. 53, no. 2, pp. 187–204, 2005.
View at: Publisher Site | Google Scholar
M. W. Friedrich, “Methyl-coenzyme M reductase genes: unique functional markers for methanogenic and anaerobic methane-oxidizing Archaea,” Methods in Enzymology, vol. 397, pp. 428–442, 2005.
View at: Publisher Site | Google Scholar
J. G. Ferry, “Enzymology of one-carbon metabolism in methanogenic pathways,” FEMS Microbiology Reviews, vol. 23, no. 1, pp. 13–38, 1999.
View at: Publisher Site | Google Scholar
D. Archer, “Methanogenesis—ecology,physiology, biochemistry and genetics—Ferry,Jg,” Nature, vol. 367, no. 64, pp. 604–605, 1994.
View at: Google Scholar
P. V. Welander and W. W. Metcalf, “Mutagenesis of the C1 oxidation pathway in Methanosarcina barkeri: new insights into the Mtr/Mer bypass pathway,” Journal of Bacteriology, vol. 190, no. 6, pp. 1928–1936, 2008.
View at: Publisher Site | Google Scholar
P. V. Welander and W. W. Metcalf, “Loss of the mtr operon in Methanosarcina blocks growth on methanol, but not methanogenesis, and reveals an unknown methanogenic pathway,” Proceedings of the National Academy of Sciences of the United States of America, vol. 102, no. 30, pp. 10664–10669, 2005.
View at: Publisher Site | Google Scholar
A. Dhillon, M. Lever, K. G. Lloyd, D. B. Albert, M. L. Sogin, and A. Teske, “Methanogen diversity evidenced by molecular characterization of methyl coenzyme M reductase A (mcrA) genes in hydrothermal sediments of the Guaymas Basin,” Applied and Environmental Microbiology, vol. 71, no. 8, pp. 4592–4601, 2005.
View at: Publisher Site | Google Scholar
D. White, The Physiology and Biochemistry of Prokaryotes, Oxford University, New York, NY, USA, 3rd edition, 2007.
M. Dworkin and S. Falkow, The Prokaryotes : A Handbook on the Biology of Bacteria, Springer, London, UK, 3rd edition, 2006.
H. Juottonen, P. E. Galand, and K. Yrjälä, “Detection of methanogenic Archaea in peat: comparison of PCR primers targeting the mcrA gene,” Research in Microbiology, vol. 157, no. 10, pp. 914–921, 2006.
View at: Publisher Site | Google Scholar
H. Cadillo-Quiroz, J. B. Yavitt, and S. H. Zinder, “Methanosphaerula palustris gen. nov., sp. nov., a hydrogenotrophic methanogen isolated from a minerotrophic fen peatland,” International Journal of Systematic and Evolutionary Microbiology, vol. 59, no. 5, pp. 928–935, 2009.
View at: Publisher Site | Google Scholar
P. E. Luton, J. M. Wayne, R. J. Sharp, and P. W. Riley, “The mcrA gene as an alternative to 16S rRNA in the phylogenetic analysis of methanogen populations in landfill,” Microbiology, vol. 148, no. 11, pp. 3521–3530, 2002.
View at: Google Scholar
C. Zhu, J. Zhang, Y. Tang, X. Zhengkai, and R. Song, “Diversity of methanogenic archaea in a biogas reactor fed with swine feces as the mono-substrate by mcrA analysis,” Microbiological Research, vol. 166, no. 1, pp. 27–35, 2011.
View at: Publisher Site | Google Scholar
X. Briand and P. Morand, “Anaerobic digestion of Ulva sp. 1. Relationship between Ulva composition and methanisation,” Journal of Applied Phycology, vol. 9, no. 6, pp. 511–524, 1997.
View at: Publisher Site | Google Scholar
R. Samson and A. LeDuy, “Biogas production from Anaerobic digestion of spirulina maxima Algal biomass,” Biotechnology and Bioengineering, vol. 24, no. 8, pp. 1919–1924, 1982.
View at: Google Scholar
A. Vergara-Fernández, G. Vargas, N. Alarcón, and A. Velasco, “Evaluation of marine algae as a source of biogas in a two-stage anaerobic reactor system,” Biomass and Bioenergy, vol. 32, no. 4, pp. 338–344, 2008.
View at: Publisher Site | Google Scholar
Q. Yan, M. Zhao, H. Miao, W. Ruan, and R. Song, “Coupling of the hydrogen and polyhydroxyalkanoates (PHA) production through anaerobic digestion from Taihu blue algae,” Bioresource Technology, vol. 101, no. 12, pp. 4508–4512, 2010.
View at: Publisher Site | Google Scholar
X. Yuan, X. Shi, D. Zhang, Y. Qiu, R. Guo, and L. Wang, “Biogas production and microcystin biodegradation in anaerobic digestion of blue algae,” Energy and Environmental Science, vol. 4, no. 4, pp. 1511–1515, 2011.
View at: Publisher Site | Google Scholar
B. A. Hales, C. Edwards, D. A. Ritchie, G. Hall, R. W. Pickup, and J. R. Saunders, “Isolation and identification of methanogen-specific DNA from blanket bog peat by PCR amplification and sequence analysis,” Applied and Environmental Microbiology, vol. 62, no. 2, pp. 668–675, 1996.
View at: Google Scholar
P. Kanokratana, T. Uengwetwanit, U. Rattanachomsri et al., “Insights into the phylogeny and metabolic potential of a primary tropical peat swamp forest microbial community by metagenomic analysis,” Microbial Ecology, vol. 61, no. 3, pp. 518–528, 2011.
View at: Publisher Site | Google Scholar
M. F. Rother, “Genetic analysis of methanogenic archaea,” 2008, http://www.uni-frankfurt.de/fb/fb15/institute/inst-3-mol-biowiss/AK-Rother/research.html/.
View at: Google Scholar
K. Tamura, J. Dudley, M. Nei, and S. Kumar, “MEGA4: Molecular Evolutionary Genetics Analysis (MEGA) software version 4.0,” Molecular Biology and Evolution, vol. 24, no. 8, pp. 1596–1599, 2007.
View at: Publisher Site | Google Scholar
K. Tamura, D. Peterson, N. Peterson, G. Stecher, M. Nei, and S. Kumar, “MEGA5: molecular evolutionary genetics analysis using maximum likelihood, evolutionary distance, and maximum parsimony methods,” Molecular Biology and Evolution, vol. 28, no. 10, pp. 2731–2739, 2011.
View at: Publisher Site | Google Scholar
K. Tamura and M. Nei, “Estimation of the number of nucleotide substitutions in the control region of mitochondrial DNA in humans and chimpanzees,” Molecular Biology and Evolution, vol. 10, no. 3, pp. 512–526, 1993.
View at: Google Scholar
R. D. Barber, L. Zhang, M. Harnack et al., “Complete genome sequence of Methanosaeta concilii, a specialist in aceticlastic methanogenesis,” Journal of Bacteriology, vol. 193, no. 14, pp. 3668–3669, 2011.
View at: Publisher Site | Google Scholar
A. Schlüter, T. Bekel, N. N. Diaz et al., “The metagenome of a biogas-producing microbial community of a production-scale biogas plant fermenter analysed by the 454-pyrosequencing technology,” Journal of Biotechnology, vol. 136, no. 1-2, pp. 77–90, 2008.
View at: Publisher Site | Google Scholar
P. E. Galand, H. Fritze, R. Conrad, and K. Yrjälä, “Pathways for methanogenesis and diversity of methanogenic archaea in three boreal peatland ecosystems,” Applied and Environmental Microbiology, vol. 71, no. 4, pp. 2195–2198, 2005.
View at: Publisher Site | Google Scholar
J. Zhu, X. Liu, and X. Dong, “Methanobacterium movens sp. nov. and Methanobacterium flexile sp. nov., isolated from lake sediment,” International Journal of Systematic and Evolutionary Microbiology, vol. 61, no. 12, pp. 2974–2978, 2011.
View at: Google Scholar
L. Cheng, T. L. Qiu, X. Li et al., “Isolation and characterization of Methanoculleus receptaculi sp. nov. from Shengli oil field, China,” FEMS Microbiology Letters, vol. 285, no. 1, pp. 65–71, 2008.
View at: Publisher Site | Google Scholar
H. Imachi, S. Sakai, Y. Sekiguchi et al., “Methanolinea tarda gen. nov., sp. nov. a methane-producing archaeon isolated from a methanogenic digester sludge,” International Journal of Systematic and Evolutionary Microbiology, vol. 58, no. 1, pp. 294–301, 2008.
View at: Publisher Site | Google Scholar
Y. Yashiro, S. Sakai, M. Ehara, M. Miyazaki, T. Yamaguchi, and H. Imachi, “Methanoregula formicica sp. nov., a methane-producing archaeon isolated from methanogenic sludge,” International Journal of Systematic and Evolutionary Microbiology, vol. 61, no. 1, pp. 53–59, 2011.
View at: Publisher Site | Google Scholar
T. Iino, K. Mori, and K. I. Suzuki, “Methanospirillum lacunae sp. nov., a methane-producing archaeon isolated from a puddly soil, and emended descriptions of the genus Methanospirillum and Methanospirillum hungatei,” International Journal of Systematic and Evolutionary Microbiology, vol. 60, no. 11, pp. 2563–2566, 2010.
View at: Publisher Site | Google Scholar

Copyright

Copyright © 2012 Joshua T. Ellis et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

PDF Download Citation

Download other formats

Order printed copies

Views

3234

Downloads

1651

Citations