Abstract

The aim of this study was to evaluate the effect of gelatin coating incorporated with Aloe vera gel () and green and black tea extracts () on physicochemical, microbial, and sensorial properties of fresh-cut oranges at 4°C for 17 days. Significant differences in terms of quality parameters were observed between the control and coated fresh-cut oranges. The highest variation of quality parameters was observed in control, while the least variations were observed in coated slices with 100% Aloe vera and 10% green tea extract. The weight loss was increased with time, but the coating treatment especially with 100% Aloe vera had significant effect on the prevention of weight loss. Also, Aloe vera coated samples obtained the highest score in sensory evaluation. Coating with gelatin incorporated with Aloe vera and green tea extracts successfully retarded the microbial growth and therefore extended the shelf life of fresh-cut oranges during cold storage.

1. Introduction

Citrus fruits have a high commercial value in the fruit market. Among them, oranges can be considered as a good source of bioactive compounds, in which their consumption would have health benefits for humans [1]. However, high moisture content and nutrient composition make this fruit more susceptible to fungi contamination [2]. It should be noted that such products are also susceptible to softening, browning, or color change and microbial contaminations, too [3]. On the other hand, peeling, cutting, or slicing increases the quality losses of fresh-cut fruits. Therefore, controlling fresh quality and growth of spoilage and pathogenic bacteria is a challenging problem for fresh-cut fruit industry [4]; and although nutrient loss could occur, preservative treatment for fresh-cut fruit is recommended.

In order to overcome the above concerns, it is recommended to use edible coatings on fresh-cut fruits to extend their shelf life. For this purpose, natural polysaccharides, proteins, and antioxidants are used as raw materials for edible coatings and films [3]. Edible coatings are thin layers of edible materials that cover the surface of food by dipping or spraying and providing a barrier to gases and water vapor and somewhere are microbial agents and therefore reduce respiration, enzymatic browning, water loss, and deleterious microbial effects [5].

Tea (Camellia sinensis) is a good source of polyphenolic compounds, which have strong antioxidant properties. Green tea and black tea differ primarily in their processing and relative levels of catechins and their oxidized condensation products. The high antioxidant capacity and overall antimicrobial activity of green tea have been attributed to these compounds [6, 7]. Such properties made us use black tea and green tea as our alternatives for coating.

Also, Aloe vera gel and gelatin have been used as edible coatings in fruit storage technology [8, 9]. The colorless mucilaginous gel of Aloe vera, consisting of approximately 99–99.5% water and 0.5–1% solid materials, includes compounds such as polysaccharides, vitamins, minerals, enzymes, phenolic compounds, and organic acids [10]. The barrier properties of Aloe vera gel coatings towards respiratory gases [11], as well as its antimicrobial functions [12], were reported in coated fruits and fresh-cut fruits.

In recent years, Aloe vera gel has been used as an edible coating for nectarines [13], sweet cherries [12], mangoes [8], apples [11, 14], papayas [15], table grapes [16], and fresh-cut kiwifruit [17, 18].

Although the effects of various edible coatings on fresh-cut fruits and vegetables have been reported by several authors, no information is available about coating of orange slices with gelatin in combination with Aloe vera and green tea and black tea extracts. Therefore, the current research was established to investigate the effect of basic edible coating (gelatin) in combination with two concentrations of Aloe vera gel and green tea and black tea extracts on the physicochemical and microbial characteristics of orange slices during storage.

2. Materials and Methods

2.1. Materials

Gelatin, 2,6-dichlorophenolindophenol, phenolphthalein, NaOH, NaCl, microbial culture media of plate count agar (PCA), and yeast extract glucose chloramphenicol (YGC) agar were purchased from Merck (Darmstadt, Germany). Orange fruits (at commercial maturity), Aloe vera leaves, and dried leaves of green tea and black tea were purchased from a local wholesale market (Yasouj, Iran).

2.2. Preparation of the Coating-Forming Solutions

Aloe vera extract was obtained from fresh aloe leaves according to the method described by Navarro et al. [19] and used intactly (for Aloe vera 100% treatment) or diluted 50 : 50 with distilled water (for Aloe vera 50% treatment) to form half concentration extract. Moreover, green tea and black tea extracts were prepared from dried tea leaves based on the method of Siripatrawan and Harte [20]. Briefly, the mixture of ground tea powders and distilled water (1 : 10 w/w) was stirred in an Erlenmeyer flask in a shaking water bath (Memmert, Germany) at 80°C and 100 oscillations/min for 10 min. Afterwards, the tea extracts were filtered through Whatman number 1 filter paper. A part of tea extracts (about 10 g) for total soluble solid content were examined by air oven method at 105°C and, according to total solid content (TSC), the final concentrations of extracts were adjusted to 5% and 10% TSC using a Rotary evaporator (Heidolph, Germany) at 45°C. Gelatin powder was dissolved in distilled water or concentration-adjusted Aloe vera and tea extracts by stirring and heating to 50°C under nitrogen gas atmosphere to form 1% gelatin solution.

2.3. Coating the Orange Slices

Oranges with uniform size and shape and without any signs of mechanical damage were selected, washed with chlorinated water (50 mgCl2/kg H2O), and finally sliced. Orange slices were dipped in the coating solutions for 1 min and then drained for 30 min. Some slices were dipped in distilled water as control samples. The prepared slices were packed in polyethylene terephthalate (PET) clamshells ( mm3) (Pars Plastic Khuzestan, Ahwaz, Iran) with four vent holes (1 mm in diameter) and stored at 4°C for 17 days. Subsequently, the following coating treatments were assigned: uncoated sample which served as control, orange slices coated with 1% gelatin, orange slices coated with 1% gelatin in combination with 50% and 100% Aloe vera gel, and 5% and 10% green tea and black tea extracts. 10 orange slices were placed in one container and three replicates were considered for each treatment on one day. The physicochemical analyses of samples were performed at 0, 5, 9, 13, and 17 days of storage.

2.4. Weight Loss Determination

The weight loss in the samples was calculated as loss in weight of the orange slices in each container during storage and the values were reported on a percentage basis [14] and calculated by the following formula:

2.5. Measurement of Total Soluble Solids (TSS), Titratable Acidity (TA), pH, and Ascorbic Acid (AA) Content

The orange slices were homogenized in a blender (Moulinex, Barcelona, Spain) and the blended puree was used to determine the total soluble solid (TSS), titratable acidity (TA), pH, and ascorbic acid content. The homogenate was centrifuged at 2000 rpm for 1 min to obtain a clear juice. TSS was determined with a refractometer (Atago NAR-3T, Tokyo, Japan) at 20°C and expressed in °Bx. TA values were determined by diluting each 10 mL aliquot of homogenized orange juice in 50 mL of distilled water and then titrated to pH 8.1 (Knick pH meter 766, Germany) by using 0.1 M NaOH. The TA results were expressed as grams of citric acid per 100 mL orange juice. Also, the ascorbic acid content was measured using a titration method with 2,6-dichlorophenolindophenol [17].

2.6. Measurement of Visual Color

Surface color of the samples was measured using a Hunter colorimeter (ColorFlex, Virginia, USA). Hunter CIE for lightness, for redness, and for yellowness were determined [17].

2.7. Microbiological Evaluation

The microbiological analyses of orange slices were carried out for total aerobic mesophilic bacteria and fungi counts in accordance with Benítez et al. [18]. Results were expressed as log CFU/g of sample.

2.8. Sensory Analysis

Sensory evaluation was performed immediately after the orange slices were removed from storage conditions. 12 untrained panelists (6 males and 6 females aged between 20 and 45 years) were responsible for sensory evaluation using a 5-point scale. The members were asked about the different quality attributes (color, aroma, flavor, and overall acceptance) of the orange slices using a hedonic scale from extremely dislike (1) to extremely like (5). Water and unsalted crackers were used in assessing the samples as palate cleansers. The rest time between tests was 1 minute.

2.9. Statistical Analysis

All experiments were run in triplicate. Statistics on a completely randomized design were performed with the analysis of variance (ANOVA) procedure in SAS (release 9.1, SAS Institute Inc., Cary, NC) software and mean comparisons were carried out by Duncan’s multiple range test ().

3. Results and Discussion

3.1. Total Soluble Solids (TSS), Titratable Acidity (TA), and pH

The effects of coating treatments on pH, TA, and TSS parameters during cold storage were shown in Figures 1(a)1(c). pH was increased significantly in all treatments during storage. The lowest increase (0.9%) in pH was observed in coated sample with 1% gelatin. In contrast, the maximum increase (~16%) was observed in samples coated with 100% Aloe vera and 5 and 10% green tea extracts. A significant increase in pH was also reported for green tea and chlorine treatments of fresh-cut lettuce. This pH increase was contributed to the growth of Gram-negative microorganisms, which play an important role in the spoilage of fresh-cut lettuce [7].

The acidity of the coated and control samples significantly reduced at different rates during the storage (). Initial acidity of samples was approximately 0.78 g/100 mL. The decreasing trend of TA in the coated samples with 100% Aloe vera and also 10% green tea extract was the highest (38–40%). In contrast, this trend for samples coated with 1% gelatin was the lowest (~14%). Similar trends for pH and TA were also reported for fresh-cut kiwifruit [18].

The TSS of control and coated samples significantly increased with storage time. In this regard, there was a significant difference between control and coated samples, as coated samples experienced a slight increase in TSS when compared to control. The highest increase of TSS was observed in control (32.40%, TSS increased from 11.9 to 15.85 after 17 days of storage at 4°C), while the lowest increase was observed in samples coated with 50% and 100% Aloe vera extract (~13.0%, TSS increased from 12.0 to 13.49 and 13.70, resp.).

The findings of this study were similar to the results of Ahmed et al. [13] and Marpudi et al. [15] who reported that TA decreased and TSS increased with increasing storage time in nectarines and papaya, respectively. Conversely, Song et al. [14] declared that the storage period did not affect the TSS of gel-coated apple slices. This result was confirmed by Bett et al. [21], too. However, Saftner et al. [22] reported that the TA decreased but TSS did not change with increasing storage time in apple slices.

Generally, it is declared that the edible coating can decrease gas permeability in slices’ surface leading to a decrease in respiration rate, which could be responsible for the lower change in TSS and TA in coated slices [12, 14, 18, 21]. It is reported that, during ripening, organic acids are used as substrates in respiration metabolism, and thereby TA would be decreased and pH and TSS would be increased. In general, it seems that total soluble solid content tends to increase over the storage period as a consequence of ripening process [18, 23]. Respiration metabolism in fruit tissues entails a progressive decrease in O2 and increase in CO2 over time under all packaging conditions [18]. The reduction of respiration rate has been observed in sweet cherry [12] and kiwifruit [18] coated with Aloe vera gel.

Titratable acidity and pH variations of green tea coated samples were higher than other samples followed by Aloe vera coated slices (Figures 1(b) and 1(c)). However, higher acidity of control and coated samples with gelatin in this study might be contributed to higher microbial population and therefore acid production by microbial flora in these samples (6.44 log CFU/g for control, Figure 3). On the other hand, the lower microbial counts of coatings containing antimicrobial agents such as green tea or Aloe vera extracts resulted in lower acid production and therefore lower acidity in these samples.

3.2. Weight Loss

The weight loss is mainly associated with moisture evaporation through the surface of fruit slices [24]. The rate of water loss depends on the water pressure gradient between the fruit tissue and the surrounding atmosphere and the storage temperature. Thus, the slicing of fruits makes them susceptible to rapid water loss, resulting in shriveling; but edible coatings are supposed to control the water loss and therefore delay the phenomenon of weight loss in fresh-cut fruits [3]. Perez-Gago et al. [25] claimed that coating application did not reduce the weight loss in fresh-cut apples, probably due to the high relative humidity in the atmosphere of the packaged product. As shown in Figure 1(d), all samples demonstrated a gradual loss of weight during storage. The weight loss in uncoated orange slices was significantly greater than those of coated samples during regular storage period. The weight loss increased with time and the highest rate of weight loss was observed in the control sample (6.72%). The least rates (2.58% and 3.72%) were observed, respectively, in the samples coated with 100% and 50% Aloe vera. Consequently, the weight loss of orange slices coated with Aloe vera gel was significantly lower than other samples (). In this regard, the Aloe vera coating was more effective than green tea and black tea coatings. Similar results were obtained by Song et al. [14]. These authors reported that the weight loss increased during storage, but the weight loss of the Aloe vera gel-coated apple slices was significantly () reduced after 8 days of storage compared to the control. The binding of Aloe vera gel molecules to the surface of apple slices might reduce the porosity of apple slices, resulting in lower water loss [14]. It is reported that Aloe vera gel reduces the respiration rate, ethylene production, weight loss, and therefore the softening of fresh-cut fruit textures [18].

Gelatin coatings show good barrier characteristics against oxygen and aroma transfers at low and intermediate relative humidity. However, they have poor barrier properties against water vapor transfer due to their hydrophilic nature [9]. Therefore, to modify the poor water vapor barrier properties of this protein film, a combined coating of gelatin with other substances may be used.

3.3. Ascorbic Acid Content

Although ascorbic acid is critical for the health, it should be noted that it is sensitive to processing and is unstable during storage period. Thus, this vitamin is often used as an indicator of the quality of fruits and vegetables in the distribution chain [26].

The ascorbic acid variations in fresh-cut oranges are shown in Figure 1(e). Statistical analysis showed that storage period at 4°C had a significant effect on the ascorbic acid content (). In terms of ascorbic acid content, a significant difference was observed among coated and control samples. The initial content of ascorbic acid in control sample (55.1 mg/100 mL orange juice) reached 42.1 mg/100 mL after 17 days of storage at 4°C, which had the highest reduction among different treatments; meanwhile the lowest reduction was found in the coated samples with 100% Aloe vera, in which their ascorbic acid contents reduced from 55.29 mg/100 mL to 48.80 mg/100 mL after 17 days of storage.

These results are in good agreement with those reported by other authors. In this regard, Plaza et al. [1] found significant reduction in ascorbic acid content (19–24% for ascorbic acid and 15–23% for total vitamin C) of whole orange fruits, hand-peeled orange fruits, and manually separated slices during 12 days of cold storage. However, there were no significant differences between whole fruits, peeled fruits, or slices at the end of refrigerated storage. Del Caro et al. [27] also reported a significant reduction in ascorbic acid content of citrus fruits slices during storage at 4°C for 12 days. It should be noted that ascorbic acid is susceptible to degradation by enzymes (ascorbate oxidase or peroxidase), light, oxygen, heat, and peroxides [1]. Ascorbic acid is the antioxidant present in fruits and vegetables and usually is destroyed after processing [7]. The slicing of fruits and vegetables induces oxidative stress, which implies a role of ascorbic acid as antioxidant [26]. The L-ascorbic acid and its oxidation product, L-dehydroascorbic acid, are biologically active. Oxidation of ascorbic acid to dehydroascorbic acid can occur by reactive oxygen species [26]. In our study, higher levels of ascorbic acid in the coated sample than in control can be attributed to good barrier characteristics of gelatin against oxygen [9] and thus reduction of oxygen levels due to respiration [18].

Despite green tea extract, increasing Aloe vera concentration showed a protective effect on ascorbic acid content. This can be attributed to the low gas permeability of Aloe vera coating which inhibited the respiratory rate [28]. But increasing green tea concentration had no significant effect on the ascorbic acid content. However, Martín-Diana et al. [7] reported that increasing green tea concentration showed a protective effect due to the antioxidant capacity of catechins, avoiding ascorbic acid degradation.

3.4. Color Change

Color is an important factor in the perception of fresh-cut fruits’ quality during their shelf life [25]. The oxidative degradation of ascorbic acid and nonenzymatic browning are reported as the major deteriorative reactions occurring during storage [29].

Figure 2 shows changes in the surface color of orange slices stored at 4°C for 17 days, as given by , , and . Statistical analysis showed that (lightness/darkness), (redness/greenness), and (yellowness/blueness) color indices significantly changed during storage. The reduction trend of values in coated and uncoated samples occurred at different rates during the storage (), showing a darkening tendency in surface color of orange slices. value of samples was in the range of 48.19–48.50 on the first day. The least reduction trend for was observed in the coated samples with 50 and 100% Aloe vera (11.07 and 8.72%, resp.) in contrast to control, which had highest reduction (28.48%). reduction during storage can be related to the occurrence of browning [7]. All of the coatings, especially Aloe vera coatings, significantly delayed the decrease of color parameter showing a clear effect on maintaining color attributes.

The color of orange slices in terms of CIE and values showed no significant () differences between the coated and uncoated samples. In other words, no significant differences were observed between all treatments during the storage time. The initial values of and parameters were about 2.35 and 24.20, which reached values ranging from 7.50 to 21.50, respectively, at the end of storage period. In this regard, a significant increase in values and significant decrease in values were observed in all treatments during storage.

Color is a critical quality property of fresh-cut fruits, since slicing of fruits may often lead to enzymatic browning by polyphenol oxidases and peroxidases, which react with phenolic compounds and cause surface browning [5, 23].

The color of orange slices and juice can be affected by different mechanisms of nonenzymatic browning such as degradation of ascorbic acid, acid-catalyzed degradation of sugars, and Maillard reactions between reducing sugars and amino acids [29]. Also, oxygen and light affect the rate of carotenoid and ascorbic acid degradation. The decrease in (yellowness) of orange is contributed to carotenoids degradation [30]. Moreover, the ascorbic acid degradation can mainly be attributed to oxygen which increases the oxidative reactions and therefore the development of brown pigments. Subsequently, the color changes may occur as a result of brown pigments formation as well as the carotenoids degradation [29].

Martín-Diana et al. [7] reported that the browning levels of coated lettuce increased with green tea extract concentrations. In other words, increasing in green tea concentrations decreased values. The amount of polyphenols present in the green tea extracts might have favored quicker appearance of browning. As green tea is a rich source of polyphenols, it can act as a good substrate for browning-related enzymes [7]. It is reported that application of an Aloe vera gel coating is an effective method for maintaining the color of fresh-cut apple slices, as the Aloe vera gel coating can act as an oxygen barrier film, retarding the enzymatic browning. However, the coating does not completely prevent oxidative browning [14]. Siripatrawan and Harte [20] declared that adding green tea extract into chitosan film significantly affected , , and values of the film surface. Films without green tea extract had higher values, while with addition of green tea extract from 0 to 20%, values decreased, while and values increased.

3.5. Microbial Analysis

The total viable counts in the fresh orange slices were ~3.25 log CFU/g for total aerobic mesophilic microorganisms and ~2.20 log CFU/g for yeast and mould. The total viable counts gradually and significantly increased with storage time in all treatments (Figure 3). The microbial population of coated sample with 1% gelatin was higher than other treatments (3.22 and 6.44 log CFU/g at 0 and 17 days of storage, resp.), while samples coated with 10% green tea extract had the lowest microbial count compared to other treatments (3.27 and 4.17 log CFU/g on day 0 and day 17 of storage period, resp.). Unexpectedly, the bacterial counts in slices coated with 1% gelatin were higher compared to control. Lower microbial population of samples coated with Aloe vera and green tea extracts is contributed to antimicrobial compounds of Aloe vera and green tea extracts [6, 18]. In contrast, different concentrations of black tea had no effect on bacterial populations. Furthermore, there was no significant difference between samples treated with black tea and control samples ().

Similar results were obtained for fungi counts, whereas gelatin coating had the highest increase and green tea extracts had the lowest increase in fungal population of orange slices during storage. The fungi count had increased from 2.15 log CFU/g to 7.16 and 7.60 log CFU/g in control and samples treated with 1% gelatin, respectively, after 17 days of storage at 4°C, while the least increase in fungi population was observed in samples coated with 5% and 10% green tea extracts (4.50 and 3.94 log CFU/g, resp.). In addition, no significant differences were observed between black tea extracts and control sample (), indicating that black tea extract had no antifungal effects. It should be noted that Aloe vera and green tea extracts reduced the microbial population, and this effect was enhanced at higher concentrations of these extracts. In both cases, the inhibition of growth was a function of Aloe vera and green tea concentration.

The inhibition of microbial growth presented in this study was in good agreement with the antimicrobial effects of Aloe vera coating in table grape [16], sweet cherry [12], apple slices [11, 14], kiwifruit slices [17], and raspberry fruit [28] which showed a reduction of mesophilic aerobic bacteria as well as yeast and mould counts during storage.

Fresh-cut fruits are highly susceptible to pathogenic and spoilage microorganisms during the preparatory steps as a consequence of cross-contamination, the presence of a large area of cut surfaces and juices, and sugars leakage from damaged tissues [5]. The microbial growth on the surface of coated apple slices showed significant differences between the coated and uncoated samples, suggesting a biopreservative function of the edible coatings [11]. Aloe vera extract was reported to have antimicrobial functions, significantly reducing mesophilic bacteria, and to especially have antifungal activity [12, 16]. Some individual components found in Aloe vera gel, such as saponins, acemannan, and anthraquinone derivatives, are known to have antibiotic activity and could be responsible for its antibacterial activity [16].

Green tea is a rich source of polyphenols (mainly catechins and catechin derivatives) that the antimicrobial activity of green tea has been attributed to these compounds [6, 7]. Black tea is the product of complete fermentation. Fermentation of tea leaves causes a reduction in the concentration of catechins and their antimicrobial activities. In general, antimicrobial activity decreased when the extents of tea fermentation increased [31]. Matan et al. [6] confirmed the antimicrobial activity in green tea extract on fresh-cut dragon. The maximum yeast count of 6 log CFU/g for nonthermal processed fruit is considered acceptable at any point of fruit product shelf life [4]. In this study, the yeast counts did exceed these levels for all samples at the end of storage, except for slices treated with Aloe vera and green tea extracts.

On the basis of our findings, the population of bacteria was less than fungi at the end of storage period. It should be noted that the susceptibility of bacteria to the antimicrobial effect of Aloe vera and green tea appears to increase with decrease in pH of the food [32], which is the case for orange with acidic pH. Moreover, our results indicated that gelatin might accelerate microbial proliferation, as the microbial counts in the fruits treated with gelatin were even higher than control samples. This may be due to the fact that gelatin coating on orange slices is a source of protein with high water activity which can be utilized by microorganisms at the absence of antimicrobials present in tea and Aloe vera extracts and this layer is not present in control samples.

In the literature of fresh-cut fruits, the impact of microbial growth on TSS, AA, and pH has not been considered, and the discussions are focused on physicochemical changes. In this regard, microbial population might play an important role. Therefore, Pearson’s correlation coefficient was used to establish the relationships between the microbial growth and some chemical parameters (Table 1).

Interestingly, highly significant correlation coefficients () were found between microbial counts, TSS, pH, AA, and weight loss. Significant correlation coefficients were observed between microbial counts and TSS, suggesting that microbial growth strongly affects the solubilization of high molecular weight compounds. In general, microorganisms on fresh-cut products fall in the category of bacteria, yeasts, and moulds. As spoilage progresses, degradation of the high molecular weight plant polymers is later brought about by moulds and pectinolytic and cellulolytic bacteria. Fruit products undergo fermentative spoilage by lactic acid bacteria or yeasts, resulting in the production of acids, alcohol, and carbon dioxide and therefore higher TA and lower pH [33]. The higher acidity of control might result from its higher moisture evaporation and therefore higher TSS. In fact, the description of changes in physicochemical characteristics is complicated, mostly due to the microorganism growth on fruit slices.

3.6. Sensory Analysis

Fresh-like quality is an important aspect in terms of consumer satisfaction, which is attributed to the color, texture, taste, and aromatic properties of the product [17]. Twelve panelists (6 males and 6 females) were asked to assess the quality of orange slices stored at 4°C on days 1, 9, and 17. Figure 4 shows the quality attribute scores (color, aroma, flavor, and overall acceptance) for the examined samples.

50 and 100% Aloe vera coated slices as well as control obtained the highest sensory scores from the viewpoint of color and aroma and flavor. But the lower scores were awarded by coated slices with green tea and black tea extracts. The color evaluation of orange slices showed a significant reduction over time, which was in consistency with the results of variations. Results showed that the overall acceptance of the orange slices was significantly reduced during storage. The highest overall acceptance was observed in 50 and 100% Aloe vera samples followed by 10% green tea. The lowest score of overall acceptance was given to control. The control and coated samples with black tea extracts showed no significant differences in terms of color and overall acceptance (). Except for green tea extract, with increasing Aloe vera and black tea extracts concentration, the panelists did not perceive any significant difference in sensorial quality at the end of storage period.

Therefore, the panelists gave greater sensory scores to aloe-coated orange slices compared to coated slices with gelatin and green tea and black tea extracts at the end of storage. Higher sensory quality of Aloe vera gel-coated apple slices compared to uncoated ones was also reported by Chauhan et al. [11] and Song et al. [14].

4. Conclusion

Edible coatings used in this study had considerable effects on some quality attributes of fresh-cut oranges. All of the gelatin-based coatings reduced weight loss, ascorbic acid degradation, and color darkening. Coatings containing green tea and Aloe vera extracts also preserved microbial quality, whereas green tea was more potent. Sensory characteristics were highly retained by Aloe vera coatings. The effects of black tea-incorporated coatings were comparable to gelatin coating and were not as effective as green tea and Aloe vera treatments. Finally, it can be concluded that gelatin coatings containing Aloe vera or green tea extracts have potential to maintain the quality and extend the shelf life of fresh-cut orange.

Additional Points

Practical Applications. Controlling the fresh quality and microbial growth is a challenging problem of fresh-cut fruit industry. Consequently, it is recommended to use edible coatings (natural polysaccharides, proteins, and antioxidants) to overcome the concerns of fresh-cut fruit storage. In recent years, Aloe vera gel and green tea extract have been used in different food types due to their health benefits. The growing use, their health benefits, easy acceptance by consumers, and their lower price in comparison with other substances incorporated in coating materials made us assess the potency of Aloe vera gel and green tea and black tea extracts for being used in coatings of fresh-cut oranges. In this regard, higher physicochemical and microbial qualities were achieved for samples coated with Aloe vera and green tea extracts. It seems that Aloe vera gel and green tea extract have the potency of being used as edible coating in food industry.

Competing Interests

The authors declare that there are no competing interests regarding the publication of this paper.

Acknowledgments

The authors would like to acknowledge Islamic Azad University, Yasooj Branch Research Council, for support of this work.