Table of Contents Author Guidelines Submit a Manuscript
Journal of Nanomaterials
Volume 2013 (2013), Article ID 157474, 6 pages
http://dx.doi.org/10.1155/2013/157474
Research Article

Preparation and Oxygen Permeability of BaCo0.7Fe0.2Nb0.1O3-δ Membrane Modified by Ce0.8Y0.2O2-δ Porous Layer on the Air Side

1School of Materials Science and Engineering, Shanghai University, Shanghai 200072, China
2Nano Science and Technology Research Center, Shanghai University, Shanghai 200444, China

Received 31 August 2013; Accepted 10 October 2013

Academic Editor: Amirkianoosh Kiani

Copyright © 2013 Yuan Qiang et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Linked References

  1. J. Shen, Z.-Z. Wang, H.-W. Yang, and R.-S. Yao, “A new technology for producing hydrogen and adjustable ratio syngas from coke ove gas,” Energy and Fuels, vol. 21, no. 6, pp. 3588–3592, 2007. View at Publisher · View at Google Scholar · View at Scopus
  2. H. J. M. Bouwmeester, H. Kruidhof, and A. J. Burggraaf, “Importance of the surface exchange kinetics as rate limiting step in oxygen permeation through mixed-conducting oxides,” Solid State Ionics, vol. 72, no. 2, pp. 185–194, 1994. View at Google Scholar · View at Scopus
  3. M. Harada, K. Domen, M. Hara, and T. Tatsumi, “Ba1.0Co0.7Fe0.2Nb0.1O3-δ dense ceramic as an oxygen permeable membrane for partial oxidation of methane to synthesis gas,” Chemistry Letters, vol. 35, no. 12, pp. 1326–1327, 2006. View at Publisher · View at Google Scholar · View at Scopus
  4. Y. Cheng, H. Zhao, D. Teng, F. Li, X. Lu, and W. Ding, “Investigation of Ba fully occupied A-site BaCo0.7Fe0.3-xNbxO3-δ perovskite stabilized by low concentration of Nb for oxygen permeation membrane,” Journal of Membrane Science, vol. 322, no. 2, pp. 484–490, 2008. View at Publisher · View at Google Scholar · View at Scopus
  5. H. Cheng, X. Lu, Y. Zhang, and W. Ding, “Hydrogen production by reforming of simulated hot coke oven gas over nickel catalysts promoted with lanthanum and cerium in a membrane reactor,” Energy and Fuels, vol. 23, no. 6, pp. 3119–3125, 2009. View at Publisher · View at Google Scholar · View at Scopus
  6. Y. S. Lin, “Microporous and dense inorganic membranes: current status and prospective,” Separation and Purification Technology, vol. 25, no. 1–3, pp. 39–55, 2001. View at Publisher · View at Google Scholar · View at Scopus
  7. R. W. Baker, “Future directions of membrane gas separation technology,” Industrial and Engineering Chemistry Research, vol. 41, no. 6, pp. 1393–1411, 2002. View at Google Scholar · View at Scopus
  8. J. Sunarso, S. Baumann, J. M. Serra et al., “Mixed ionic-electronic conducting (MIEC) ceramic-based membranes for oxygen separation,” Journal of Membrane Science, vol. 320, no. 1-2, pp. 13–41, 2008. View at Publisher · View at Google Scholar · View at Scopus
  9. J. W. Stevenson, T. R. Armstrong, R. D. Carneim, L. R. Pederson, and W. J. Weber, “Electrochemical properties of mixed conducting perovskites La1-xMxCo1-yFeyO3-δ (M = Sr, Ba, Ca),” Journal of the Electrochemical Society, vol. 143, no. 9, pp. 2722–2729, 1996. View at Google Scholar · View at Scopus
  10. T. Ishihara, T. Yamada, H. Arikawa, H. Nishiguchi, and Y. Takita, “Mixed electronic-oxide ionic conductivity and oxygen permeating property of Fe-, Co- or Ni-doped LaGaO3 perovskite oxide,” Solid State Ionics, vol. 135, no. 1–4, pp. 631–636, 2000. View at Publisher · View at Google Scholar · View at Scopus
  11. Z. P. Shao, G. X. Xiong, J. H. Tong et al., “Ba effect in doped Sr(Co0. 8Fe0. 2)O3-δ on the phase structure and oxygen permeation properties of the dense ceramic membranes,” Separation and Purification Technology, vol. 25, no. 1–3, pp. 419–429, 2001. View at Google Scholar
  12. H. Wang, Y. Cong, and W. Yang, “Investigation on the partial oxidation of methane to syngas in a tubular Ba0.5Sr0.5Co0.8Fe0.2O3-δ membrane reactor,” Catalysis Today, vol. 82, no. 1–4, pp. 157–166, 2003. View at Publisher · View at Google Scholar · View at Scopus
  13. S. Liu and G. R. Gavalas, “Oxygen selective ceramic hollow fiber membranes,” Journal of Membrane Science, vol. 246, no. 1, pp. 103–108, 2005. View at Publisher · View at Google Scholar · View at Scopus
  14. W. Jin, S. Li, P. Huang, N. Xu, and J. Shi, “Preparation of an asymmetric perovskite-type membrane and its oxygen permeability,” Journal of Membrane Science, vol. 185, no. 2, pp. 237–243, 2001. View at Publisher · View at Google Scholar · View at Scopus
  15. S. M. Murphy, D. A. Slade, K. J. Nordheden, and S. M. Stagg-Williams, “Increasing oxygen flux through a dense oxygen permeable membrane by photolithographic patterning of platinum,” Journal of Membrane Science, vol. 277, no. 1-2, pp. 94–98, 2006. View at Publisher · View at Google Scholar · View at Scopus
  16. A. Thursfield and I. S. Metcalfe, “Air separation using a catalytically modified mixed conducting ceramic hollow fibre membrane module,” Journal of Membrane Science, vol. 288, no. 1-2, pp. 175–187, 2007. View at Publisher · View at Google Scholar · View at Scopus
  17. A. Leo, S. Liu, J. C. Diniz da Costa, and Z. Shao, “Oxygen permeation through perovskite membranes and the improvement of oxygen flux by surface modification,” Science and Technology of Advanced Materials, vol. 7, no. 8, pp. 819–825, 2006. View at Publisher · View at Google Scholar · View at Scopus
  18. S. Li, L. Ge, H. Gu, Y. Zheng, H. Chen, and L. Guo, “Sinterability and electrical properties of ZnO-doped Ce0.8Y0.2O1.9 electrolytes prepared by an EDTA-citrate complexing method,” Journal of Alloys and Compounds, vol. 509, no. 1, pp. 94–98, 2011. View at Publisher · View at Google Scholar · View at Scopus
  19. Q. Zhen, Q. Yuan, H. Wang, C. Ding, W. Ding, and X. Lu, “Investigation of chemical stability and oxygen permeability of perovskite-type Ba0.5Sr0.5Co0.8Fe0.2O3-δ and BaCo0.7Fe0.2Nb0.1O3-δ ceramic membranes,” Solid State Ionics, vol. 198, no. 6, pp. 50–55, 2011. View at Google Scholar · View at Scopus
  20. B. C. H. Steele, “Appraisal of Ce1-yGdyO2-y/2 electrolytes for IT-SOFC operation at 500°C,” Solid State Ionics, vol. 129, no. 1, pp. 95–110, 2000. View at Publisher · View at Google Scholar · View at Scopus
  21. M. Mogensen, N. M. Sammes, and G. A. Tompsett, “Physical, chemical and electrochemical properties of pure and doped ceria,” Solid State Ionics, vol. 129, no. 1, pp. 63–94, 2000. View at Publisher · View at Google Scholar · View at Scopus
  22. Q. Yuan, Q. Zhen, R. Li, L. Gao, and L. Ni, “Reaction mechanism of preparing Bi0.75Dy0.25O1.5 nanopowder by the reverse titration chemical coprecipitation method,” Journal of University of Science and Technology Beijing, vol. 32, no. 2, pp. 245–249, 2010. View at Google Scholar · View at Scopus
  23. Q. Zhen, G. M. Kale, G. Shi et al., “Processing of dense nanocrystalline Bi2O3-Y2O3 solid electrolyte,” Solid State Ionics, vol. 176, no. 30, pp. 2727–2733, 2005. View at Google Scholar
  24. Q. Zhen, R. N. Vannier, and G. M. Kale, “Preparation of dense nanocrystalline Bi2O3-HfO2-Y2O3 ceramic by microwave plasma sintering,” Materials Science and Engineering A, vol. 444, no. 1-2, pp. 130–137, 2007. View at Google Scholar
  25. N. N. Dinh, N. T. T. Oanh, P. D. Long et al., “Electrochromic properties of TiO2 anatase thin films prepared by a dipping sol-gel method,” Thin Solid Films, vol. 423, no. 1, pp. 70–76, 2003. View at Google Scholar
  26. E. Barrera, T. Viveros, A. Avila et al., “Cobalt oxide films grown by a dipping sol-gel process,” Thin Solid Films, vol. 346, no. 1-2, pp. 138–144, 1999. View at Google Scholar
  27. H. Hayashi, H. Inaba, M. Matsuyama, N. G. Lan, M. Dokiya, and H. Tagawa, “Structural consideration on the ionic conductivity of perovskite-type oxides,” Solid State Ionics, vol. 122, no. 1–4, pp. 1–15, 1999. View at Publisher · View at Google Scholar · View at Scopus
  28. Y. Eraoka, M. Yoshimatsu, N. Yamazoe, and T. Seiyama, “Oxygen-sorptive properties and defect structure of perovskite-type oxides,” Chemistry Letters, vol. 6, pp. 893–896, 1984. View at Google Scholar