Table of Contents Author Guidelines Submit a Manuscript
Mathematical Problems in Engineering
Volume 2015, Article ID 130790, 14 pages
http://dx.doi.org/10.1155/2015/130790
Research Article

Diagnosis of Intermittent Faults in IGBTs Using the Latent Nestling Method with Hybrid Coloured Petri Nets

1Facultad de Ingeniería, Universidad EAN, Bogotá, Colombia
2Departamento de Ingeniería de Sistemas y Automática, Instituto Universitario de Automática e Informática Industrial, Universitat Politècnica de València, Camino de Vera, s/n, 46022 Valencia, Spain

Received 14 October 2014; Revised 26 December 2014; Accepted 6 January 2015

Academic Editor: GuanJun Liu

Copyright © 2015 Leonardo Rodriguez-Urrego et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Linked References

  1. J. R. Celaya, A. Saxena, P. Wysocki, S. Saha, and K. Goebel, “Towards prognostics of power MOSFETs: accelerated aging and precursors of failure,” in Proceedings of the Annual Conference of the Prognostics and Health Management Society, 2010.
  2. M. A. Rodríguez-Blanco, A. Claudio-Sánchez, D. Theilliol et al., “A failure-detection strategy for IGBT based on gate-voltage behavior applied to a motor drive system,” IEEE Transactions on Industrial Electronics, vol. 58, no. 5, pp. 1625–1633, 2011. View at Publisher · View at Google Scholar · View at Scopus
  3. H. Qi, S. Ganesan, and M. Pecht, “No-fault-found and intermittent failures in electronic products,” Microelectronics Reliability, vol. 48, no. 5, pp. 663–674, 2008. View at Publisher · View at Google Scholar · View at Scopus
  4. F. Filsecker, R. Alvarez, and S. Bernet, “Comparison of 4.5-kV press-pack IGBTs and IGCTs for medium-voltage converters,” IEEE Transactions on Industrial Electronics, vol. 60, no. 2, pp. 440–449, 2013. View at Publisher · View at Google Scholar · View at Scopus
  5. M. Trabelsi, M. Boussak, P. Mestre, and M. Gossa, “An improved diagnosis technique for IGBTs open-circuit fault in PWM-VSI-fed induction motor drive,” in Proceedings of the IEEE International Symposium on Industrial Electronics (ISIE '11), pp. 2111–2117, June 2011. View at Publisher · View at Google Scholar · View at Scopus
  6. H. Chen and S. Lu, “Fault diagnosis digital method for power transistors in power converters of switched reluctance motors,” IEEE Transactions on Industrial Electronics, vol. 60, no. 2, pp. 749–763, 2013. View at Publisher · View at Google Scholar · View at Scopus
  7. W. Sleszynski, J. Nieznanski, and A. Cichowski, “Open-transistor fault diagnostics in voltage-source inverters by analyzing the load currents,” IEEE Transactions on Industrial Electronics, vol. 56, no. 11, pp. 4681–4688, 2009. View at Publisher · View at Google Scholar · View at Scopus
  8. B. Lu and S. K. Sharma, “A literature review of IGBT fault diagnostic and protection methods for power inverters,” IEEE Transactions on Industry Applications, vol. 45, no. 5, pp. 1770–1777, 2009. View at Publisher · View at Google Scholar · View at Scopus
  9. S. M. A. Cruz, M. Ferreira, A. M. S. Mendes, and A. J. M. Cardoso, “Analysis and diagnosis of open-circuit faults in matrix converters,” IEEE Transactions on Industrial Electronics, vol. 58, no. 5, pp. 1648–1661, 2011. View at Publisher · View at Google Scholar · View at Scopus
  10. V. Smet, F. Forest, J.-J. Huselstein et al., “Ageing and failure modes of IGBT modules in high-temperature power cycling,” IEEE Transactions on Industrial Electronics, vol. 58, no. 10, pp. 4931–4941, 2011. View at Publisher · View at Google Scholar · View at Scopus
  11. P. Venet, G. Grellet, and G. Rojat, “Identification of significant parameters relative to failure during operation of a switch-mode power supply application to preventive diagnostic,” EPE Journal, vol. 3, pp. 112–116, 1991. View at Google Scholar
  12. F. Filippetti, G. Franceschini, C. Tassoni, and P. Vas, “Recent developments of induction motor drives fault diagnosis using AI techniques,” IEEE Transactions on Industrial Electronics, vol. 47, no. 5, pp. 994–1004, 2000. View at Publisher · View at Google Scholar · View at Scopus
  13. NASA, “RCM guide realiability-centered maintenance guide for facilities and collateral equipment,” NASA Technical Report, NASA, 2008. View at Google Scholar
  14. B. Lu, Y. Li, X. Wu, and Z. Yang, “A review of recent advances in wind turbine condition monitoring and fault diagnosis,” in Proceedings of the IEEE Power Electronics and Machines in Wind Applications (PEMWA '09), pp. 1–7, June 2009. View at Publisher · View at Google Scholar · View at Scopus
  15. A. Maouad, A. Hoffmann, A. Khoury, and J.-P. Charles, “Characterization of high-density current stressed IGBTs and simulation with an adapted SPICE sub-circuit,” Microelectronics Reliability, vol. 40, no. 6, pp. 973–979, 1999. View at Publisher · View at Google Scholar · View at Scopus
  16. J. O. Estima and A. J. M. Cardoso, “A new approach for real-time multiple open-circuit fault diagnosis in voltage-source inverters,” IEEE Transactions on Industry Applications, vol. 47, no. 6, pp. 2487–2494, 2011. View at Publisher · View at Google Scholar · View at Scopus
  17. G. Sonnenfeld, K. Goebel, and J. R. Celaya, “An agile accelerated aging, characterization and scenario simulation system for gate controlled power transistors,” in Proceedings of the IEEE AUTOTESTCON, pp. 208–215, September 2008. View at Publisher · View at Google Scholar · View at Scopus
  18. E. García, L. Rodríguez, F. Morant, A. Correcher, E. Quiles, and R. Blasco, “Fault diagnosis with Coloured Petri Nets using Latent Nestling Method,” in Proceedings of the IEEE International Symposium on Industrial Electronics (ISIE '08), pp. 986–991, July 2008. View at Publisher · View at Google Scholar · View at Scopus
  19. E. García, L. Rodriguez, F. Morant, A. Correcher, and E. Quiles, “Latent Nestling Method: a new fault diagnosis methodology for complex systems,” in Proceedings of the 34th Annual Conference of the IEEE Industrial Electronics Society (IECON '08), pp. 253–258, November 2008. View at Publisher · View at Google Scholar · View at Scopus
  20. L. Rodríguez, E. García, F. Morant, A. Correcher, and E. Quiles, “Application of latent nestling method using coloured petri nets for the fault diagnosis in the wind turbine subsets,” in Proceedings of the 13th IEEE International Conference on Emerging Technologies and Factory Automation (ETFA '08), pp. 767–773, Hamburg, Germany, September 2008. View at Publisher · View at Google Scholar · View at Scopus
  21. L. Rodríguez, E. García, F. Morant, E. Quiles, and A. Correcher, “Application of latent nestling method using coloured petri nets for the fault diagnosis in the wind turbine subsets,” in Proceedings of the IEEE International Symposium on Diagnostics for Electrical Machines, Power Electronics & Devices (SDEMPED '11), September 2011.
  22. J. Gertler, Fault Detection and Diagnosis in Engineering Systems, Marcel Dekker, New York, NY, USA, 1998.
  23. R. J. Patton and J. Chen, “Observer-based fault detection and isolation: robustness and applications,” Control Engineering Practice, vol. 5, no. 5, pp. 671–682, 1997. View at Publisher · View at Google Scholar · View at Scopus
  24. R. J. Patton, C. J. López-Toribio, and F. J. Uppal, “Artificial intelligence approaches to fault diagnosis for dynamic systems,” International Journal of Applied Mathematics and Computer Science, vol. 9, no. 3, pp. 471–518, 1999. View at Google Scholar
  25. R. David and H. Alla, Discrete, Continuous, and Hybrid Petri Nets, Springer, 2005.
  26. I. Demongodin and N. T. Koussoulas, “Differential Petri nets: representing continuous systems in a discrete-event world,” IEEE Transactions on Automatic Control, vol. 43, no. 4, pp. 573–579, 1998. View at Publisher · View at Google Scholar · View at Scopus
  27. A. Correcher, E. García, F. Morant, E. Quiles, and L. Rodríguez, “Intermittent failure dynamics characterization,” IEEE Transactions on Reliability, vol. 61, no. 3, pp. 649–658, 2012. View at Publisher · View at Google Scholar
  28. M. A. Rodríguez, A. Claudio, D. Theilliol, and L. G. Vela, “A new fault detection technique for IGBT based on gate voltage monitoring,” in Proceedings of the IEEE Power Electronics Specialists Conference (PESC '07), pp. 1001–1005, June 2007. View at Publisher · View at Google Scholar · View at Scopus