Abstract

A feeding experiment was conducted to investigate the effect of fermented Terminalia catappa fruit meal (FTCM) with Aspergillus niger as replacement for maize on broiler growth performance, nutrient digestibility, and serum biochemical constituents. Dietary maize was replaced by FTCM at 0, 20, 40, 60, or 80%. One hundred and eighty one-day-old Shaver broiler chicks were randomly allocated to the five dietary treatments, three replicate groups of twelve chicks each for a 42-day period. There was no significant difference ( ) in the feed intake, weight gain, and feed; gain ratio between the broilers fed on 40% FTCM diet and the control group. The apparent digestibilities of nitrogen, crude fibre, and fat decreased significantly in broilers fed higher levels ( 40%) of FTCM replacement diets compared with the control or lower FTCM diets. Serum concentrations of total protein, albumin, and globulin were decreased ( ) on 80% FTCM fed broilers. Serum cholesterol, creatinine, and glucose were not significantly ( ) altered among treatments. The activities of aspartate and alanine aminotransferases and alkaline phosphatase were significantly ( ) increased with higher FTCM replacement. The results indicate that FTCM could replace up to 40% of dietary maize in the diets of broiler chickens without adverse effect on growth performance or serum constituents.

1. Introduction

The high cost and scarcity of conventional feed ingredients constitute major problems facing commercial poultry production in the developing countries of the world. In Nigeria, maize is the most commonly used source of energy for poultry and usually constitutes 40%–60% of industrially formulated poultry diets. The high cost of maize and other cereals is due to the competition between man and farm animals for grains, and the seasonal production. Many unconventional tropical feed resources, especially crop seeds and their by-products which have potential for use as alternative sources of feed for poultry, could be exploited to reduce cost and limit the dependence on maize [1–3].

One of such is the fruit of the Terminalia catappa tree, which is abundant in the tropics, where it is grown for ornamental purposes. The plant forms layers of canopy and branches which bear clusters of fruits. This fruit, also known as Almond fruit, has membranous epicarp, succulent mesocarp, and fibrous endocarp that enclose the seed. The Terminalia tree has a conservative estimated yield of 75 kg of fruits per year, which have long been wasted in the field. These fruits, if collected, could be used in animal feeds. Although the fruit provides natural sources of soluble carbohydrates, phosphorus, and fibre [4], the presence of secondary plant metabolites, also referred to as antinutritional factors (ANFs), such as haemagglutinin, tannin and phytic acid in the raw seed could interfere with growth rate and nutrient utilization when fed to rats unless these ANFs are eliminated or reduced to insignificant levels by heat treatments [5–7]. The high proportion of fibre (200 g kg-1) in the whole fruit [3] also limits the extent to which it can be used directly in diet formulation for monogastric animals, especially poultry, which lack the appropriate digestive enzymes for degrading fibre [8, 9].

With other fibrous crop by-products, their nutritional value is known to be improved through solid-state fermentation (SSF) which breaks down the high-fibre materials by the action of microorganisms, particularly fungi [10–12]. Moreover, it has been shown that SSF could induce degradation of antinutritional and toxic components in plant feedstuffs [13–15]. Studies by Iyayi and Aderolu [16] showed that diets containing fibrous agroindustrial by-products fermented with Trichoderma viride culture significantly enhanced laying hens’ performance. Hong et al. [17] and Feng et al. [18] found that soybean meal fermented with Aspergillus oryzea was highly digestible and chicks fed the meal exhibited improved growth performance, increased concentrations of serum immunoglobulin and total phosphorus, and decreased urea nitrogen level. Adebiyi [19] concluded that fermentation with mono and mixed cultures of fungi, which contained Aspergillus niger, Trichoderma viride, and Rhizopus oligosporus, was beneficial for improved utilization of the potential of cowpea seed hull in the diets of meat-type chicken. However, this improvement could be less with high-fibre tree fruits [20].

At present, the data about the effect of fermented whole fruit from T. catappa on the performance of poultry are limited. Therefore, this experiment was conducted to evaluate the growth performance, nutrient digestibility, and serum biochemical constituents of broiler chickens fed diets containing A. niger fermented whole T. catappa fruit as replacement for maize.

2. Materials and Methods

2.1. Preparation of Fermented Terminalia catappa Fruit Meal

Mature and ripe fruits from T. catappa tree were collected within the campus of the University of Ilorin, Nigeria. Samples (150 kg) of the whole fruit were washed to remove dirts, sun-dried for 10 days, milled, and then subjected to SSF process. The fungus used for fermentation was Aspergillus niger TC-4 and the stock were obtained from the Microbiology Laboratory, University of Ilorin.

In preparing suspension, A. niger TC-4 was cultivated on Potato-Dextrose Agar (PDA) at C for 7 days, after which it was subcultured to obtain a pure suspension containing  spore ml-1 following the procedure outlined by Hesseltine [23]. A batch (1 kg) of the T. catappa whole fruit meal was autoclaved at C for 15 min. Autoclaved meal was cooled to room temperature for 1 h, hydrated with distilled water at a ratio of 1 : 1.5 (w/v), and inoculated with 20 ml of spore suspension of A. niger per kg of wet meal. The meal was thoroughly mixed and fermented in an air-tight plastic bucket for 7 days. At the end of the fermentation period, A. niger fermented T. catappa fruit meal was covered by a thin layer of black mycelium which knitted the substrate into a cake. The fresh fermented cake was then reautoclaved at C for 15 min to destroy A. niger and sun-dried for 5 days. The dried product was ground in the mill, packed in polythene sack, sealed and stored at ambient temperature until sampled for analysis, and mixed into diets described below.

2.2. Chemical Analysis

All analyses were performed in triplicate. Fermented T. catappa fruit meal (FTCM) and T. catappa fruit meal (TCM) were analysed for their proximate and detergent fibre contents by the methods of AOAC [24] and Van Soest et al. [25], respectively. Tannin was quantified gravimetrically based on the method of Joslyn [26]. Phytic acid was determined by the colorimetric technique of Wheeler and Ferrel [27] as modified by Rao and Deosthale [28]. Oxalate was assayed using the procedure described by Ranjhan and Krishna [29].

2.3. Diets, Chicks, and Management

Five diets (230 g crude protein kg-1) were formulated by replacing maize with FTCM at 0, 20, 40, 60, and 80% levels (Table 1). The diet without FTCM served as control. One hundred and eighty one-day-old Shaver broiler chicks of equal male and female were obtained from a local hatchery. The birds were divided into five groups of 36 chicks each, which were randomly allocated to the five dietary treatments using a completely randomized design. Each treatment had three replicate cage units of 12 chicks. The chicks were allowed free access to water and experimental diets. Routine management was followed throughout the study period of 42 d. The initial and weekly body weight of broilers was measured in each cage. Feed intake value was obtained from weekly records by subtracting the weight of feed remaining at the end of each week from the total weight introduced during the week. Feed: gain ratio was calculated by dividing the average amount of feed intake per broiler by the average weight gain for each replicate group.

2.4. Digestibility Trial

On day 35, a digestibility trial was carried out with the broiler chickens. Weighed quantities of the diets were supplied and faeces were collected over 72 h in plastic sheeting placed under the wire mesh floor of the cage using the total collection method. Faeces were collected every 24 h, weighed, and stored at C. At the end of the trial, the daily samples collected from broilers in each replicate cage were pooled into 1 sample, oven dried ( C for 20 h), weighed and ground with approximately 10% retained, and stored in airtight Kilner jars. Duplicate samples of diets and dried faeces were analysed for proximate components by AOAC [24] methods and the values were used to compute apparent nutrient digestibility.

2.5. Blood Sampling and Serum Constituents Assay

At the end of the 42-d period, two chickens were randomly selected from each replicate and whole blood samples were collected from the wing vein into clean dry test tubes and allowed to stay at room temperature for 3 h. Samples were centrifuged at 1600   g for 15 min to harvest the serum. Serum samples were stored at C until thawed and used for biochemical analysis. Serum total protein, albumin, globulin, creatinine, glucose, and cholesterol were determined by the methods of Sirois [30] and alanine aminotransferase (ALT, EC 2.6.1.2), aspartate aminotransferase (AST, EC 2.6.1.1), and alkaline phosphatase (AP, EC 3.1.3.1) activities were measured by using commercial clinical investigation kits (Wako, Osaka, Japan).

2.6. Statistical Analysis

The data from the feeding trial were subjected to one-way analysis of variance, and multiple comparisons among means were made by Duncan’s multiple range test using the SPSS version 10.0 computer program [31]. Other data were compared using Student’s -test. All statements of differences were based on significance at .

3. Results and Discussion

The analytical data for T. catappa fruit meal (TCM) and fermented T. catappa fruit meal (FTCM) are shown in Table 2. After 7 days fermentation, the crude protein increased ( ) while the crude fibre and fat contents decreased significantly, particularly the fibre level by about 50% relative to the unfermented fruit meal. Fermentation induced significant ( ) degradation of detergent fibre and antinutritional components of TCM. The reduction in neutral detergent fibre and acid detergent fibre ranged between 21% and 24%. Tannin and phytic acid had reductions of 59% and 35%, respectively. There was a slight decrease in oxalate content.

The present study shows that fermentation changed the characteristics of T. catappa fruit meal. The increase in crude protein content of the FTCM may be due in part to the synthesis of single cell protein by the proliferation of the fungus used. This is supported by Fonseca et al. [32], who reported that microorganisms contributed microbial protein to their fermented products. The decreases in crude fibre, detergent fibre, and fat contents may be attributed to the degradation by extra cellular enzymes secreted by A. niger; this strain secretes a number of enzymes including alpha-galactosidase, hemicellulase, and pectinase [33]. During fermentation, the enzymes secreted are known to metabolise carbohydrate as a carbon source for growth of the strain [34]. The marked reductions in phytic acid and tannin contents after fermentation might have been caused by the activity of intrinsic phytase or hydrolysis by A. niger. These findings are in agreement with Reddy and Pierson [14] and Khattab and Arntfield [35], who reported appreciable reductions in the tannin and phytic acid contents of cereals and legumes, respectively. They found that the fermentation microflora hydrolysed phytic acid into inositol and orthophosphate.

The growth performance characteristics of broilers fed diets with FTCM replacing maize are presented in Table 3. Feed intake, weight gain, and feed; gain ratio for the broilers on the 20% and 40% FTCM replacement for maize diets (FRM) were similar ( ) to those of the control group, while at higher FRM levels these performance characteristics were lower ( ) than the control. There was no mortality at all levels during the feeding trial. The higher feed intake with lower levels of FRM may have occurred as a result of the flavour compounds produced during SSF which improved the palatability of the fermented meal [36, 37]. The absence of significant difference in weight gain and feed; gain ratio of broilers fed the control diet and those fed 40% FRM diet suggests that this level of FRM which corresponds to 180 g kg-1 FTCM in the diet can support growth and feed conversion comparable to a maize-based diet. Previous report of Bakrie [10] showed that there was an improvement in weight gain and feed efficiency of broilers fed diet containing cassava fibre fermented with A. niger.

The apparent nutrient digestibility values are given in Table 4. Digestion of nitrogen, fibre, and fat with 20% and 40% FRM was significantly better than those on higher levels of FRM. Digestion of nitrogen was higher with 20% FRM. The enhanced nutrient digestibility with lower levels of FRM might have contributed to the growth pattern of the broilers, as evidenced by the increase growth rate in broilers on lower FRM diets. The reduction in nutrient digestibility with higher FRM diets may partly be a consequence of the high crude fibre in these diets (Table 1). This would affect the digestion and intestinal absorption of associated nutrients in the diets. Adeniji and Omonijo [38] reported that fibres are arranged in such a way that proteins are trapped within them offering resistance to digestion by enzymes in gastrointestinal tract of simple-stomached animals. In the present study, the residual tannin in FTCM (Table 2) could also contribute to the decrease in nitrogen digestibility observed in broilers fed higher levels of FRM. Tannin found in sorghum grains [39] and a number of legume seeds [40] have been implicated in the reduced nutrient digestibility of these feedstuffs.

The serum biochemical constituents of the broilers are presented in Table 5. Values for total protein, albumin, and globulin were similar ( ) to the control until 60% of the maize was replaced by FTCM. Cholesterol, creatinine, and glucose concentrations were not significantly altered by dietary treatments. AST, ALT, and AP activities with the 60% and 80% FRM diets were significantly higher than the control, but the lower levels were not. The values of the serum metabolites in broilers fed 20%–60% FRM diets were within normal ranges [41], reflecting a normal metabolism in the broilers fed these levels of FRM diets. This observation could also suggest that FTCM can spare dietary maize at those substitution levels. However, the decrease in total protein concentration with 80% FRM diet is an indication of reduction in protein synthesis which could probably be related to the low feed intake observed in the diet. The increases in serum AST and ALT activities with 80% FRM diet indicate a release of the transaminases from cytoplasm into the blood stream which is probably due to the damage of the hepatocytes and/or other tissues. A similar observation has been reported by Muhammad and Oloyede [42] for chicks fed fermented T. cattapa seed meal-based diet.

In conclusion, the present study showed that the solid-state fermentation of T. catappa fruit meal using A. niger could improve the nutritional characteristics of T. catappa and decrease the inherent tannin and phytic acid components. The FTCM has a high potential as feedstuff for poultry and could be included at 180 g kg-1 to replace 40% dietary maize level in the broiler chicken feed without adverse effect on growth performance, apparent nutrient digestibility, or serum biochemical constituents.

Acknowledgments

The author is grateful to Dr. R.M.O Kayode of Food Science Department, University of Ilorin, Nigeria, for technical assistance in preparing the FTCM, to Atteh M. and Babatayo K. for care and management of the broilers during the experiment.