Table of Contents Author Guidelines Submit a Manuscript
Journal of Chemistry
Volume 2013 (2013), Article ID 234904, 13 pages
http://dx.doi.org/10.1155/2013/234904
Research Article

Full Factorial Experimental Design Analysis of Reactive Dye Removal by Carbon Adsorption

Chemical and Process Engineering Department, Engineering Faculty, Gulumbe Campus, Bilecik Seyh Edebali University, 11210 Bilecik, Turkey

Received 28 May 2013; Revised 22 July 2013; Accepted 24 July 2013

Academic Editor: Subrata Mondal

Copyright © 2013 N. Özbay et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Linked References

  1. E. N. El Qada, S. J. Allen, and G. M. Walker, “Adsorption of basic dyes from aqueous solution onto activated carbons,” Chemical Engineering Journal, vol. 135, no. 3, pp. 174–184, 2008. View at Publisher · View at Google Scholar · View at Scopus
  2. T. Shen, Industrial Pollution Prevention, Spring, Berlin, Germany, 1995.
  3. P. Cooper, “Removing colour from dyehouse wastewaters—a critical review of technology available,” Journal of the Society of Dyers and Colourists, vol. 109, no. 3, pp. 97–100, 1993. View at Google Scholar · View at Scopus
  4. S. B. Jadhav, S. S. Phugare, P. S. Patil, and J. P. Jadhav, “Biochemical degradation pathway of textile dye Remazol red and subsequent toxicological evaluation by cytotoxicity, genotoxicity and oxidative stress studies,” International Biodeterioration and Biodegradation, vol. 65, no. 6, pp. 733–743, 2011. View at Publisher · View at Google Scholar · View at Scopus
  5. V. K. Gupta, B. Gupta, A. Rastogi, S. Agarwal, and A. Nayak, “A comparative investigation on adsorption performances of mesoporous activated carbon prepared from waste rubber tire and activated carbon for a hazardous azo dye—Acid Blue 113,” Journal of Hazardous Materials, vol. 186, no. 1, pp. 891–901, 2011. View at Publisher · View at Google Scholar · View at Scopus
  6. M. F. Elkady, A. M. Ibrahim, and M. M. A. El-Latif, “Assessment of the adsorption kinetics, equilibrium and thermodynamic for the potential removal of reactive red dye using eggshell biocomposite beads,” Desalination, vol. 278, no. 1–3, pp. 412–423, 2011. View at Publisher · View at Google Scholar · View at Scopus
  7. G. S. Gupta, S. P. Shukla, G. Prasad, and V. N. Singh, “China clay as an adsorbent for dye house wastewaters,” Environmental Technology, vol. 13, no. 10, pp. 925–936, 1992. View at Google Scholar · View at Scopus
  8. J. Sokolowska-Gajda, H. S. Freeman, and A. Reife, “Synthetic dyes based on environmental considerations. Part 2: iron complexed formazan dyes,” Dyes and Pigments, vol. 30, no. 1, pp. 1–20, 1996. View at Publisher · View at Google Scholar · View at Scopus
  9. O. Tünay, I. Kabdaşli, D. Orhon, and G. Cansever, “Use and minimization of water in leather tanning processes,” Water Science and Technology, vol. 40, no. 1, pp. 237–244, 1999. View at Publisher · View at Google Scholar · View at Scopus
  10. K. Ivanov, E. Gruber, W. Schempp, and D. Kirov, “Possibilities of using zeolite as filler and carrier for dyestuffs in paper,” Das Papier, vol. 4, no. 7-8, pp. 450–456, 1996. View at Google Scholar
  11. A. Slampova, D. Smela, A. Vondrackova, I. Jancarova, and V. Kuban, “Determination of synthetic colorants in foodstuffs,” Chemicke Listy, vol. 95, pp. 163–168, 2001. View at Google Scholar
  12. S. M. F. Cook and D. R. Linden, “Use of rhodamine WT to facilitate dilution and analysis of atrazine samples in short-term transport studies,” Journal of Environmental Quality, vol. 26, no. 5, pp. 1438–1440, 1997. View at Google Scholar · View at Scopus
  13. R. W. Wagner and J. S. Lindsey, “Boron-dipyrromethene dyes for incorporation in synthetic multi-pigment light-harvesting arrays,” Pure and Applied Chemistry, vol. 68, no. 7, pp. 1373–1380, 1996. View at Google Scholar · View at Scopus
  14. D. Wróbel, A. Boguta, and R. M. Ion, “Mixtures of synthetic organic dyes in a photoelectrochemical cell,” Journal of Photochemistry and Photobiology A, vol. 138, no. 1, pp. 7–22, 2001. View at Google Scholar · View at Scopus
  15. C. Scarpi, F. Ninci, M. Centini, and C. A. Cecilia Anselmi, “High-performance liquid chromatography determination of direct and temporary dyes in natural hair colourings,” Journal of Chromatography A, vol. 796, no. 2, pp. 319–325, 1998. View at Publisher · View at Google Scholar · View at Scopus
  16. A. Srinivasan and T. Viraraghavan, “Decolorization of dye wastewaters by biosorbents: a review,” Journal of Environmental Management, vol. 91, no. 10, pp. 1915–1929, 2010. View at Publisher · View at Google Scholar · View at Scopus
  17. P. Kaushik and A. Malik, “Fungal dye decolourization: recent advances and future potential,” Environment International, vol. 35, no. 1, pp. 127–141, 2009. View at Publisher · View at Google Scholar · View at Scopus
  18. M. A. Ahmad and N. K. Rahman, “Equilibrium, kinetics and thermodynamic of Remazol Brilliant Orange 3R dye adsorption on coffee husk-based activated carbon,” Chemical Engineering Journal, vol. 170, no. 1, pp. 154–161, 2011. View at Publisher · View at Google Scholar · View at Scopus
  19. M. A. Ahmad and R. Alrozi, “Optimization of rambutan peel based activated carbon preparation conditions for Remazol Brilliant Blue R removal,” Chemical Engineering Journal, vol. 168, no. 1, pp. 280–285, 2011. View at Publisher · View at Google Scholar · View at Scopus
  20. K. Santhy and P. Selvapathy, “Removal of reactive dyes from wastewater by adsorption on coir pith activated carbon,” Bioresource Technology, vol. 97, no. 11, pp. 1329–1336, 2006. View at Publisher · View at Google Scholar · View at Scopus
  21. I. M. Banat, P. Nigam, D. Singh, and R. Marchant, “Microbial decolorization of textile-dye-containing effluents: a review,” Bioresource Technology, vol. 58, pp. 217–227, 1996. View at Google Scholar
  22. V. K. Konaganti, R. Kota, S. Patil, and G. Madras, “Adsorption of anionic dyes on chitosan grafted poly(alkyl methacrylate)s,” Chemical Engineering Journal, vol. 158, no. 3, pp. 393–401, 2010. View at Publisher · View at Google Scholar · View at Scopus
  23. A. Gürses, Ç. Doǧar, S. Karaca, M. Açikyildiz, and R. Bayrak, “Production of granular activated carbon from waste Rosa canina sp. seeds and its adsorption characteristics for dye,” Journal of Hazardous Materials, vol. 131, no. 1–3, pp. 254–259, 2006. View at Publisher · View at Google Scholar · View at Scopus
  24. D. D. Asouhidou, K. S. Triantafyllidis, N. K. Lazaridis, and K. A. Matis, “Adsorption of Remazol Red 3BS from aqueous solutions using APTES- and cyclodextrin-modified HMS-type mesoporous silicas,” Colloids and Surfaces A, vol. 346, no. 1–3, pp. 83–90, 2009. View at Publisher · View at Google Scholar · View at Scopus
  25. G. Crini, “Non-conventional low-cost adsorbents for dye removal: a review,” Bioresource Technology, vol. 97, no. 9, pp. 1061–1085, 2006. View at Publisher · View at Google Scholar · View at Scopus
  26. K. R. Ramakrishna and T. Viraraghavan, “Dye removal using low cost adsorbents,” Water Science and Technology, vol. 36, no. 2-3, pp. 189–196, 1997. View at Publisher · View at Google Scholar · View at Scopus
  27. V. K. Gupta and S. Suhas, “Application of low-cost adsorbents for dye removal—a review,” Journal of Environmental Management, vol. 90, no. 8, pp. 2313–2342, 2009. View at Publisher · View at Google Scholar · View at Scopus
  28. A. Mittal, D. Kaur, and J. Mittal, “Applicability of waste materials-bottom ash and deoiled soya-as adsorbents for the removal and recovery of a hazardous dye, brilliant green,” Journal of Colloid and Interface Science, vol. 326, no. 1, pp. 8–17, 2008. View at Publisher · View at Google Scholar · View at Scopus
  29. Z. Aksu and I. A. Isoglu, “Use of agricultural waste sugar beet pulp for the removal of Gemazol turquoise blue-G reactive dye from aqueous solution,” Journal of Hazardous Materials, vol. 137, no. 1, pp. 418–430, 2006. View at Publisher · View at Google Scholar · View at Scopus
  30. N. K. Amin, “Removal of reactive dye from aqueous solutions by adsorption onto activated carbons prepared from sugarcane bagasse pith,” Desalination, vol. 223, no. 1–3, pp. 152–161, 2008. View at Publisher · View at Google Scholar · View at Scopus
  31. S. Senthilkumaar, P. Kalaamani, K. Porkodi, P. R. Varadarajan, and C. V. Subburaam, “Adsorption of dissolved Reactive red dye from aqueous phase onto activated carbon prepared from agricultural waste,” Bioresource Technology, vol. 97, no. 14, pp. 1618–1625, 2006. View at Publisher · View at Google Scholar · View at Scopus
  32. V. K. Gupta, A. Mittal, L. Kurup, and J. Mittal, “Adsorption of a hazardous dye, erythrosine, over hen feathers,” Journal of Colloid and Interface Science, vol. 304, no. 1, pp. 52–57, 2006. View at Publisher · View at Google Scholar · View at Scopus
  33. V. K. Gupta, A. Mittal, A. Malviya, and J. Mittal, “Adsorption of carmoisine A from wastewater using waste materials—Bottom ash and deoiled soya,” Journal of Colloid and Interface Science, vol. 335, no. 1, pp. 24–33, 2009. View at Publisher · View at Google Scholar · View at Scopus
  34. A. Mittal, L. Kurup, and V. K. Gupta, “Use of waste materials—Bottom Ash and De-Oiled Soya, as potential adsorbents for the removal of Amaranth from aqueous solutions,” Journal of Hazardous Materials, vol. 117, no. 2-3, pp. 171–178, 2005. View at Publisher · View at Google Scholar · View at Scopus
  35. V. K. Gupta, R. Jain, and S. Varshney, “Removal of Reactofix golden yellow 3 RFN from aqueous solution using wheat husk—an agricultural waste,” Journal of Hazardous Materials, vol. 142, no. 1-2, pp. 443–448, 2007. View at Publisher · View at Google Scholar · View at Scopus
  36. K. Y. Foo and B. H. Hameed, “Preparation and characterization of activated carbon from sunflower seed oil residue via microwave assisted K2CO3 activation,” Bioresource Technology, vol. 102, no. 20, pp. 9794–9799, 2011. View at Publisher · View at Google Scholar · View at Scopus
  37. National Sunflower Association, Sunflower Statistics, 2012, http://www.sunflowernsa.com/stats/world-supply.
  38. B. H. Hameed, “Equilibrium and kinetic studies of methyl violet sorption by agricultural waste,” Journal of Hazardous Materials, vol. 154, no. 1–3, pp. 204–212, 2008. View at Publisher · View at Google Scholar · View at Scopus
  39. M. Cantamutto and M. Poverene, “Genetically modified sunflower release: opportunities and risks,” Field Crops Research, vol. 101, no. 2, pp. 133–144, 2007. View at Publisher · View at Google Scholar · View at Scopus
  40. Z.-Y. Zhong, Q. Yang, X.-M. Li, K. Luo, Y. Liu, and G.-M. Zeng, “Preparation of peanut hull-based activated carbon by microwave-induced phosphoric acid activation and its application in Remazol Brilliant Blue R adsorption,” Industrial Crops and Products, vol. 37, no. 1, pp. 178–185, 2012. View at Publisher · View at Google Scholar · View at Scopus
  41. P. Sathishkumar, M. Arulkumar, and T. Palvannan, “Utilization of agro-industrial waste Jatropha curcas pods as an activated carbon for the adsorption of reactive dye Remazol Brilliant Blue R (RBBR),” Journal of Cleaner Production, vol. 22, no. 1, pp. 67–75, 2012. View at Publisher · View at Google Scholar · View at Scopus
  42. M. Jain, V. K. Garg, and K. Kadirvelu, “Equilibrium and kinetic studies for sequestration of Cr(VI) from simulated wastewater using sunflower waste biomass,” Journal of Hazardous Materials, vol. 171, no. 1–3, pp. 328–334, 2009. View at Publisher · View at Google Scholar · View at Scopus
  43. A. P. Vieira, S. A. A. Santana, C. W. B. Bezerra et al., “Kinetics and thermodynamics of textile dye adsorption from aqueous solutions using babassu coconut mesocarp,” Journal of Hazardous Materials, vol. 166, no. 2-3, pp. 1272–1278, 2009. View at Publisher · View at Google Scholar · View at Scopus
  44. A. Y. Dursun and O. Tepe, “Removal of Chemazol Reactive Red 195 from aqueous solution by dehydrated beet pulp carbon,” Journal of Hazardous Materials, vol. 194, pp. 303–311, 2011. View at Publisher · View at Google Scholar · View at Scopus
  45. K. E. Lee, N. Morad, T. T. Teng, and B. T. Poh, “Factorial experimental design for reactive dye flocculation using inorganic-organic composite polymer,” APCBEE Procedia, vol. 1, pp. 59–65, 2012. View at Google Scholar
  46. G. Annadurai, R.-S. Juang, and D.-J. Lee, “Factorial design analysis for adsorption of dye on activated carbon beads incorporated with calcium alginate,” Advances in Environmental Research, vol. 6, no. 2, pp. 191–198, 2002. View at Publisher · View at Google Scholar · View at Scopus
  47. V. Ponnusami, V. Krithika, R. Madhuram, and S. N. Srivastava, “Biosorption of reactive dye using acid-treated rice husk: factorial design analysis,” Journal of Hazardous Materials, vol. 142, no. 1-2, pp. 397–403, 2007. View at Publisher · View at Google Scholar · View at Scopus
  48. Y. Safa and H. N. Bhatti, “Adsorptive removal of direct textile dyes by low cost agricultural waste: application of factorial design analysis,” Chemical Engineering Journal, vol. 167, no. 1, pp. 35–41, 2011. View at Publisher · View at Google Scholar · View at Scopus
  49. N. F. Cardoso, R. B. Pinto, E. C. Lima et al., “Removal of remazol black B textile dye from aqueous solution by adsorption,” Desalination, vol. 269, no. 1–3, pp. 92–103, 2011. View at Publisher · View at Google Scholar · View at Scopus
  50. Z. Mbolekwa and C. Buckley, “Dye removal with activated carbon for the reuse of salt, water and energy,” Industrial Wastewater Treatment, WISA, 2006. View at Google Scholar
  51. S. M. A. Guelli Ulson de Souza, L. C. Peruzzo, and A. A. Ulson de Souza, “Numerical study of the adsorption of dyes from textile effluents,” Applied Mathematical Modelling, vol. 32, no. 9, pp. 1711–1718, 2008. View at Publisher · View at Google Scholar · View at Scopus
  52. F. R. Furlan, L. G. de Melo da Silva, A. F. Morgado, A. A. U. de Souza, and S. M. A. Guelli Ulson de Souza, “Removal of reactive dyes from aqueous solutions using combined coagulation/flocculation and adsorption on activated carbon,” Resources, Conservation and Recycling, vol. 54, no. 5, pp. 283–290, 2010. View at Publisher · View at Google Scholar · View at Scopus
  53. E. C. Lima, B. Royer, J. C. P. Vaghetti et al., “Adsorption of Cu(II) on Araucaria angustifolia wastes: determination of the optimal conditions by statistic design of experiments,” Journal of Hazardous Materials, vol. 140, no. 1-2, pp. 211–220, 2007. View at Publisher · View at Google Scholar · View at Scopus
  54. Y. Safa and H. N. Bhatti, “Biosorption of direct red-31 and direct orange-26 dyes by rice husk: application of factorial design analysis,” Chemical Engineering Research and Design, vol. 89, no. 12, pp. 2566–2574, 2011. View at Publisher · View at Google Scholar · View at Scopus
  55. A. Rathinam, J. R. Rao, and B. U. Nair, “Adsorption of phenol onto activated carbon from seaweed: determination of the optimal experimental parameters using factorial design,” Journal of the Taiwan Institute of Chemical Engineers, vol. 42, no. 6, pp. 952–956, 2011. View at Publisher · View at Google Scholar · View at Scopus
  56. D. Bingol, N. Tekin, and M. Alkan, “Brilliant Yellow dye adsorption onto sepiolite using a full factorial design,” Applied Clay Science, vol. 50, no. 3, pp. 315–321, 2010. View at Publisher · View at Google Scholar · View at Scopus