Investigation of Cytotoxicity, Oxidative Stress, and Inflammatory Responses of Tantalum Nanoparticles in THP-1-Derived Macrophages

Zhang, Li; Haddouti, El-Mustapha; Beckert, Hannes; Biehl, Ralf; Pariyar, Shyam; Rüwald, Julian M.; Li, Xian; Jaenisch, Max; Burger, Christof; Wirtz, Dieter C.; Kabir, Koroush; Schildberg, Frank A.

doi:https://doi.org/10.1155/2020/3824593

Mediators of Inflammation

On this page

Abstract Introduction Materials and Methods Results Discussion Conclusions Data Availability Conflicts of Interest Authors’ Contributions Acknowledgments Supplementary Materials References Copyright Related Articles

Special Issue

Mediators of Inflammation in Bone Physiology and Diseases

View this Special Issue

Research Article | Open Access

Volume 2020 | Article ID 3824593 | https://doi.org/10.1155/2020/3824593

Investigation of Cytotoxicity, Oxidative Stress, and Inflammatory Responses of Tantalum Nanoparticles in THP-1-Derived Macrophages

Li Zhang,¹El-Mustapha Haddouti,¹Hannes Beckert,²Ralf Biehl,³Shyam Pariyar,⁴Julian M. Rüwald,¹Xian Li,⁵Max Jaenisch,¹Christof Burger,¹Dieter C. Wirtz,¹Koroush Kabir,¹and Frank A. Schildberg¹

Academic Editor: Marietta Herrmann

Received31 Jul 2020

Revised29 Oct 2020

Accepted02 Nov 2020

Published04 Dec 2020

Abstract

Tantalum (Ta) is gaining attention as a biomaterial in bone tissue engineering. Although the clinical advantage of Ta-based implants for primary and revision total joint replacement (TJA) has been well documented, few studies investigated the effect of wear products of Ta implants on peri-implant cells, and their potential contribution to aseptic implant loosening. This study is aimed at examining the cytotoxicity, oxidative stress, and proinflammatory potential of Ta and TiO₂ nanoparticles (NPs) on macrophages in vitro. NPs were characterized using scanning electron microscopy, dynamic light scattering, and energy-dispersive X-ray. To test the NP-mediated cellular response in macrophages, THP-1-derived macrophages were challenged with both NPs, and cytotoxicity was analyzed using CCK-8 and LDH assays. Flow cytometry was used to investigate particle uptake and their internalization routes. NP-mediated oxidative stress was investigated by measuring the production of reactive oxygen species, and their proinflammatory potential was determined by quantifying the production of TNFα and IL-1β in cell culture supernatants using ELISA. We found that both Ta and TiO₂ NPs were taken up through actin-dependent phagocytosis, although TiO₂ NPs did also show some involvement of macropinocytosis and clathrin-mediated endocytosis. Ta NPs caused no apparent toxicity, while TiO₂ NPs demonstrated significant cytotoxicity at a concentration of over 100μg/mL at 24 h. Ta NPs induced negligible ROS generation and proinflammatory cytokines (TNFα, IL-1β) in macrophages. In contrast, TiO₂ NPs markedly induced these effects in a dose-dependent manner. Our findings indicate that Ta NPs are inert, nontoxic, and noninflammatory. Therefore, Ta could be considered an excellent biomaterial in primary and revision joint arthroplasty implants.

1. Introduction

Aseptic loosening is the leading cause of revision surgery and plays a predominant role in limiting the longevity of current total joint arthroplasty (TJA). Wear particles have been recognized as one of the major factors responsible for aseptic implant loosening [1]. After implantation, orthopedic prosthesis becomes an internal source of wear particles [2–5]. Upon corrosion and abrasion, nondegradable biomaterial wear particles are inevitably released in adjacent peri-implant tissues or systemically disseminated, inducing local and systemic reactions [6–8]. They represent a long-term hazard that interacts with peri-implant cell lineages such as macrophages, fibroblasts, osteoblasts, osteoclasts, and mesenchymal stem cells (MSCs). This process may disrupt local cellular functions; create chronic inflammation, which favors periprosthetic osteolysis; and eventually leads to aseptic implant loosening with subsequent revision surgery. Clinically, as the only established treatment for periprosthetic aseptic loosening, revision TJA is technically demanding and associated with high complication rates, high morbidity, and poor clinical and functional outcomes. Moreover, because of the complexity of the procedure, compromised soft tissue, and bone defects, revision TJA has a greater failure rate than primary TJA [9]. Therefore, choosing the appropriate implant biomaterial is critical for the long-term survival of both primary and revision TJAs.

Tantalum (Ta) is described as an “extremely bioinert” material and has been widely applied as artificial joints, endovascular stents, and coating [10–12]. As biomaterial for implant components in primary and revision TJA, Ta can be formed with a highly porous structure that could mimic the structure of cancellous bone. Similar to titanium (Ti), Ta provides outstanding biocompatibility and corrosion resistance [13, 14]. Moreover, porous Ta components offer lower elastic modulus and higher surface frictional characteristics than conventional Ti implants, thus reducing shielding and improving early stability. These properties make Ta an ideal choice in TJA revision surgery [15, 16]. Recent studies on failed Ta implant revision hip arthroplasty described nanoscale Ta fragments (diameters ranging from 9.6 to 243.5 nm) released from the implant surface [17, 18]. Because of this phagocytozable size range and spatial proximity, Ta nanoparticles (NPs) could be internalized by peri-implant cells, e.g., macrophages, fibroblasts, and MSCs, and provoke hazardous cellular responses. However, the difficulties in purifying and characterizing NPs until today result in an underestimation of the adverse impact of Ta NPs. Therefore, particular attention must be paid to nanoscale Ta wear particles’ potentially hazardous effect on peri-implant cells and their potential contribution to repeated prosthetic loosening and subsequent rerevision [19]. However, to date, this topic remains largely unknown.

Macrophages are the critical cells associated with wear particle-induced aseptic loosening. As sentinels of the innate immune system, macrophages are the first immune cells involved in aseptic loosening by recognizing, internalizing, and getting activated upon wear particle exposure [20, 21]. Once activated, macrophages exert an increased proinflammatory phenotype and initiate a chronic inflammatory response characterized by the release of proinflammatory mediators, such as TNFα, IL-1β, monocyte chemotactic protein-1 (MCP-1), and IL-8 [21, 22]. These reactions create an inflammatory microenvironment that facilitates elevated osteoclastic bone destruction, suppressed bone formation, and ultimately lead to aseptic implant loosening. Therefore, an attempt to elucidate macrophages’ response to biomaterial wear debris is critical to understanding the pathology of implant loosening.

The biological response of peri-implant cells to implants is critical for early and late implant success. Recently, emerging in vitro and in vivo studies on osteoblasts and MSCs have demonstrated the Ta-based implants’ advantages over commonly used Ti-based implants [23–25]. However, limited research investigated the interaction between Ta implants and other peri-implant cells, such as macrophages. In particular, the biological response of macrophages to Ta implants’ wear products, such as nanoscale Ta particles and ions, has never been elucidated. Therefore, this study is aimed at analyzing the effects of Ta NPs on macrophage biology using the THP-1 cell line, an in vitro cell model that is well known, reproducible, and readily available to different labs. To this end, we investigated Ta NPs’ uptake routes, cytotoxicity, oxidative stress, and proinflammatory potential on THP-1-derived macrophages in vitro.

2. Materials and Methods

2.1. Cell Culture and Differentiation

THP-1 cells (American Type Culture Collection, Manassas, VA, USA), a human monocytic leukemia-derived cell line, were cultured in RPMI 1640 medium supplemented with 10% fetal bovine serum and 1% penicillin/streptomycin at 37°C in a humidified atmosphere with 5% CO₂. For macrophage differentiation, the THP-1 cells were stimulated with 50ng/mL phorbol 12-myristate 13-acetate (PMA) (Sigma-Aldrich, Taufkirchen, Germany) overnight.

2.2. Particle Preparation

Ta (NM-0036-HP) and TiO₂ (NO-0046-HP) nanosized particles were obtained from IoLiTec (Heilbronn, Germany), weighed into autoclaved tubes, and then sterilized by radiation. Stock dispersions (50 mg/mL) were prepared in phosphate-buffered saline (PBS) solution, followed by 20min of continuous sonication using the Emmi-12HC (EMAG AG, Germany) bath sonicator operating at 45kHz at 30°C. Then, the stock solution was stored at 4°C in the dark. Final dispersions were prepared from a serial dilution of the stock in full cell culture medium followed by another 20min sonication at 30°C and vigorous vortexing for 5s immediately before adding them to the cells.

2.3. Characterization of Particles

The physicochemical properties of particles were analyzed with scanning electron microscopy (SEM) and dynamic light scattering (DLS). The particle morphology and size distribution were determined with SEM. Samples dispersed in ddH₂O were vortexed before applying 2μL of the mixture onto a silicon wafer. After drying the sample, the wafer was sputtered with an ~2nm platinum layer in a Leica ACE600 sputter coater in an argon atmosphere to prepare it for high-resolution field-emission scanning electron microscopy (FESEM) (Crossbeam 550, Zeiss). A Schottky emitter-based field emission Gemini II electron column (Zeiss) was used with 0.8kV acceleration voltages and currents between 150pA and 250pA for imaging. The samples were imaged with the InLens SE (secondary electrons) detector (Zeiss) for topographic imaging (). ImageJ (NIH) software was used to determine the size distribution of NPs by randomly selecting 100 particles from the SEM images. The size distribution of NPs was fitted using a Gaussian distribution in GraphPad Prism 7 software (GraphPad, La Jolla, CA, USA).

The DLS experiment was carried out with Zetasizer Nano-ZS (Malvern, Worcestershire, Great Britain), which estimates the size distribution from the measured correlation function by nonnegative least square (NNLS) analysis. TiO₂ and Ta NPs were dispersed in ddH₂O, PBS, RPMI 1640, and RPMI 1640 containing 10% FBS. Then, samples of NPs were mixed thoroughly via sonication and vortexing before measuring them at 250μg/mL. The scattered light is monitored at an angle of 173° with a wavelength of 633 nm. Measurements were done at 20°C at an average of 10-20 short frames of 10 s. The observed decay rate is with scattering vector . The hydrodynamic radius is related to the diffusion coefficient according to the Stokes-Einstein equation with the Boltzmann constant , temperature (in K), and viscosity of the solvent.

The energy-dispersive X-ray (EDX) analysis was performed using the EDX system (EDAX, Ametek GmbH, Meerbusch, Germany). The EDX system is fitted with a Super Ultrathin Window Si-(Li) detector with a (MnKα at 1000 cps), configured with a take-off angle of 45° relative to the microscope stage. The Genesis 4000 software (version 3.61) was used to display and evaluate the collected spectra. Measuring adjustments (; ; ; and ) remained constant during the measurements. The time required for the analysis of each sample was 655 live seconds. Al, Ta, Si, Ti, Fe, Co, and Ni, were chosen for quantification, whereas the other elements such as carbon, oxygen, nitrogen, potassium, and magnesium were not considered (Supplementary Figure 2). Quantification of the elements was standardless using the ZAF-algorithm and selecting the automatic integration of the obtained spectra. The evaluated parameters were the standardized amounts of Ta and Ti.

2.4. Endotoxin Test

Endotoxin levels in nanoparticle samples were quantified with the Limulus amebocyte lysate (LAL) assay using the ToxinSensor™ Chromogenic LAL Endotoxin Assay Kit (Genscript) according to the manufacturer’s instructions with modifications. This kit has a minimum endotoxin detection limit of 0.01EU/mL and a measurable concentration range of 0.01 to 1EU/mL. 100μg raw NPs were suspended in 1mL endotoxin-free water at 100μg/mL. A volume of 100μL NP suspension and 100μL of endotoxin standard samples derived from Escherichia coli (0.01-0.1 unit/mL) were incubated with 100μL reconstituted LAL reagent for 30min at 37°C and a volume of 100μL endotoxin-free water as control. After the initial incubation, 100μL reconstituted chromogenic substrate solution was added into each vial, and the incubation continued for an additional 6min. The reaction was stopped by adding 500μL of reconstituted color-stabilizer #1 (stop solution). Then, 500μL of reconstituted color-stabilizer #2 and #3 were added. Importantly, particles were removed by two rounds of centrifugation (2500 rpm for 15 min) as they may interfere with the absorbance value [26]. Finally, the absorbance value of each reaction was determined at 545nm using a microplate reader. Distilled water was used as a blank to adjust the photometer to zero absorbance. All samples (100μL) were analyzed in duplicate. Only tests producing a correlation coefficient for the standard curve of 0.98 or greater were accepted. Because NPs may interfere with the endotoxin measurement, all NP samples were measured with and without aliquots of a test sample containing a known amount of the endotoxin (0.005 EU/mL). The assays were considered reliable if the recovery of spikes was 80-120%.

2.5. Cell Viability Assay

The CCK-8 Cell Counting Kit (Dojindo, Japan) was used to evaluate the viability of macrophages that were treated with TiO₂ and Ta NPs. Briefly, THP-1 cells were seeded in 96-well cell culture plates () with PMA and incubated overnight for differentiation. Cells were then challenged with a series of concentrations of NPs (20, 50, 100, 200, and 500μg/mL and 0.2mL/well) for 1h, h, 6h, 1d, 3d, and 7d. At the end of each time point, the medium was replaced with fresh culture medium containing CCK-8 solution (1 : 10 in culture medium), and further incubated for another hour at 37°C and 5% CO₂. The supernatant was collected and transferred to another 96-well plate to avoid the interference of NPs on optical density (OD) reading. Finally, absorbance was measured at 450 nm using a microplate reader (Tecan, Männedorf, Switzerland). The viability of the nonchallenged cells was considered 100%.

2.6. Lactate Dehydrogenase Release Assay

Cell culture supernatants from THP-1-derived macrophages were collected after 1, 3, and 7 days after NP exposure. Resulting supernatants were evaluated for LDH activity using the Cytotoxicity LDH Assay Kit-WST (Dojindo, Japan). The absorbance of all samples at a wavelength of 490 nm was recorded using a microplate reader. Low controls (untreated cells) and high controls (cells treated with lysis buffer) were used to calculate the cell mortality:

2.7. Measurement of Nanoparticle Uptake by Flow Cytometry

Particle uptake by macrophages was measured via flow cytometry. THP-1 cells were seeded into 24-well cell culture plates at cells per well with PMA overnight. Then, THP-1 cells were preincubated for 30min with the following uptake inhibitors: 25 μM cytochalasin D (CytD), used to disrupt actin-dependent phagocytosis [27]; 100 μM amiloride (Ame), applied as an inhibitor of micropinocytosis [28]; and 25μM genistein (Gen) and 25 μM chlorpromazine hydrochloride (Cpz), used to inhibit caveolae- and clathrin-mediated endocytosis, respectively [29]. Cells were subsequently exposed to TiO₂ or Ta NPs at concentrations of 100 and 500μg/mL (0.5mL/well) for 1 and 6h. The inhibitors were not removed during the uptake experiments. At the end of each time point, cells were trypsinized and centrifuged. The resulting cell pellet was resuspended in 200μL ice-cold PBS and analyzed with flow cytometry. Flow cytometry data were acquired using FACSCanto II using FACS-Diva software and analyzed using FlowJo software (all from BD Biosciences). Cell profiles were investigated through forward scatter (FSC) vs. side scatter (SSC) to exclude cell debris and free particles. Mean SSC was used as a measure of particle uptake. The increase in SSC, which was directly related to the cellular granularity, was analyzed as described previously [30]. SSC increases at 4°C, which indicates the passive, energy-independent entrance of particles into cells, and a portion of particles adherent to macrophages’ outer membranes were analyzed and subtracted from the data acquired at 37°C.

2.8. Bright-Field Microscopy

THP-1 cells were differentiated as described above in a 12-well chamber slide (35mm) (ibidi, Germany) and treated for 24 h with standard culture medium, TiO₂, and Ta NPs. Bright-field microscope images were taken using an IX81 microscope (Olympus).

2.9. Measurement of Intracellular ROS Generation

The generation of intracellular ROS was measured using 2,7-dichlorodihydrofluorescein diacetate (DCFH-DA, Sigma-Aldrich). PMA-differentiated THP-1 cells ( in 96-well plates) were washed with warm PBS and then treated with TiO₂ or Ta NPs at 50 to 500μg/mL for 1, 3, 6, and 24h. N-Acetyl-L-cysteine (NAC) was applied in some experiments to inhibit ROS production. For these tests, PMA-differentiated THP-1 cells were pretreated with 10 mM NAC for 30min and then stimulated with 100 or 500μg/mL NPs for another 6 or 24h in the presence of 10 mM NAC. Then, serum-free RPMI medium containing 20μM DCFH-DA was added to the samples and controls for another 30min under standard culturing conditions. Untreated controls were maintained for each time interval. Subsequently, cells were carefully washed twice with prewarmed PBS. The fluorescence intensity of the resulting fluorescent product dichlorofluorescein (DHF) was measured with a microplate reader at the excitation and emission wavelengths of 485 and 530 nm, respectively.

2.10. Enzyme-Linked Immunosorbent Assay (ELISA)

PMA-differentiated THP-1 cells ( of a 96-well plate) were firstly primed with 200ng/mL LPS (LPS-EK Ultrapure, InvivoGen) or incubated with standard culture medium for 3 h. Then, LPS was removed, and macrophages were treated with particles for 1h, 3h, 6h, 1d, 3d, and 7d. NAC was applied in some experiments to inhibit ROS in THP-1 macrophages. For these tests, PMA-differentiated THP-1 cells were pretreated with 10mM NAC for 30min following LPS priming and then stimulated with 100 or 500μg/mL NPs for another 6 h in the presence of 10mM NAC. Cell-free supernatants were collected and centrifuged (, 10min, 4°C), and aliquots were stored at -80°C. TNFα and IL-1β were determined with an ELISA kit (R&D Systems, Wiesbaden, Germany) according to the manufacturer’s protocol, using a microplate ELISA reader.

2.11. Statistical Analysis

GraphPad Prism 7 software was used for statistical analysis. All values were expressed as the . Student’s -test was used for comparisons between two groups, and one-way ANOVA was used to determine statistical differences between several groups. Differences were considered significant at , , and .

3. Results

3.1. Nanoparticle Characterization

SEM images of TiO₂ NPs (Figure 1(a)) and Ta NPs (Figure 1(b)) exhibited a spherical shape. TiO₂ NPs were slightly more plate-like, with less rounded features. The average size of the TiO₂ and Ta particles estimated from SEM images was (Figure 1(c)) and (Figure 1(d)), respectively. To further characterize the size distribution of particles in the liquid phase, TiO₂ and Ta NPs were analyzed using dynamic light scattering (DLS). The hydrodynamic sizes of TiO₂ and Ta NPs in ddH₂O, PBS, RPMI 1640 growth medium, and RPMI 1640 growth medium containing 10% FBS are summarized in Supplementary Table 1. The DLS results demonstrated that both NPs had the tendency to form aggregates in different solutions. In addition, endotoxin levels were also tested in both groups by employing the LAL chromogenic assay. All NP samples did not show any contamination with endotoxins (Supplementary Figure 1), confirming that all particle samples could be considered endotoxin-free. To confirm NP purity, energy-dispersive X-ray (EDX) analyses were performed. The resulting EDX spectra of NPs indicated the presence of Ti and Ta as the main elements, with no indication of other selected elements (Supplementary Figure 2). Notably, our EDX data revealed some extent of oxidation of Ta NPs, which may be attributed to the formation of an oxide layer on the surface of Ta NPs during sample preparation.

(a)

(b)

(c)

(d)

3.2. Bright-Field Microscopy of THP-1-Derived Macrophages Exposed to TiO₂ and Ta NPs

To observe the interaction between THP-1-derived macrophages and NPs, THP-1-derived macrophages were exposed to culture medium (Figure 2(a)), TiO₂ NPs (Figure 2(b)), and Ta NPs (Figure 2(c)) for 24h, and bright-field images were taken. Bright-field images showed the presence of TiO₂ and Ta NP agglomerates in the presence of THP-1-derived macrophages.

(a)

(b)

(c)

3.3. Analysis of the Cytotoxic Effect of TiO₂ and Ta NPs in THP-1-Derived Macrophages

THP-1-derived macrophages were exposed to TiO₂ and Ta NPs using a concentration range of 20-500μg/mL. Cell viability was evaluated by CCK-8 assay. TiO₂ NPs demonstrated no dose-dependent cytotoxicity until they reached a threshold of 200μg/mL at 24 hours (Figure 3(a)). Beyond this limit, TiO₂ NPs significantly decreased macrophage viability in a dose- and time-dependent manner compared to untreated cells (Supplementary Figure 3(a)). In contrast, exposure of macrophages to 20-500 μg/mL Ta NPs did not result in a significant decrease in cell viability (Figure 3(b), Supplementary Figure 3(b)) until 7 days. Notably, at 24 and 48h using 20μg/mL, cell viability was even slightly increased (Supplementary Figure 3(b)). As Ta’s density is higher than that of TiO₂, we also compared 100μg/mL TiO₂ with 500μg/mL Ta to compensate a potential bias by NP density. Similar to the direct comparison between the same NP concentrations, cells were still less viable in the presence of 100μg/mL TiO₂ than in the presence of 500μg/mL Ta NPs.

(a)

(b)

(c)

(d)

LDH is being released by cells as a consequence of cell membrane damage, and therefore, it is an indicator of irreversible cell death. As expected, the LDH release assay congruently supported our CCK-8 cell viability results. Compared to untreated cells, in the TiO₂ NP group, there was no appreciable cell death until 24 hours. Then, increasing cell death was observed in a dose- and time-dependent manner (Figure 3(c), Supplementary Figure 3(c)). In contrast, exposure of macrophages to 20-500μg/mL Ta NPs for up to 7 days did not result in a significant increase in cell death (Figure 3(d), Supplementary Figure 3(d)). Overall, TiO₂ and Ta NPs demonstrated good biocompatibility at low concentrations. At high concentrations, however, only TiO₂ NPs led to cytotoxicity.

3.4. Cellular Uptake and Internalization Routes of TiO₂ and Ta NPs

Macrophages are phagocytic cells capable of sensing and internalizing particulate matters. To validate the uptake of TiO₂ and Ta NPs, THP-1 macrophages were exposed to TiO₂ and Ta NPs (100 and 500 μg/mL) for 1 and 6 h, and flow cytometry was used to quantify NP uptake. Flow cytometric analysis demonstrated that both TiO₂ and Ta NPs significantly enhanced cell granularity, which was detected by SSC signals and can be used as a readout for NP uptake. We observed significantly lower SSC signals in the Ta NP group in contrast to the TiO₂ group (Figure 4) at 1 and 6 h, suggesting that THP-1-derived macrophages took up more TiO₂ NPs than Ta NPs at the same concentration.

(a)

(b)

(c)

(d)

Figure 4

TiO₂ and Ta NP internalization and their particle-specific uptake routes. THP-1-derived macrophages were pretreated with different uptake inhibitors for 30min and then exposed to (a) TiO₂ and (b) Ta NPs at 100 and 500μg/mL for 1 and 6 h. Changes in side scatter (SSC) were analyzed with flow cytometry. SSC changes at 4°C were subtracted, and data were expressed as as fold of NP-untreated cells (Nc) of three independent experiments. Statistical differences were shown as , , and for inhibitor-treated groups vs. cells treated with particles only.

To determine possible uptake routes of TiO₂ and Ta NPs, THP-1-derived macrophages were preincubated with different uptake inhibitors before NP exposure. Comparison of the FACS analysis data at 1 and 6 h demonstrated that the majority of the particles were internalized within the first hour (Figure 4). To ensure that the uptake inhibitors did not affect cell viability, cell viability was tested in the presence of different inhibitor concentrations up to 6 hours (Supplementary Figure 4).

As shown in Figures 4(a) and 4(b), the uptake of TiO₂ and Ta NPs was significantly reduced after preincubation with CytD, Ame, and Cpz, but not Gen, suggesting that macrophages take up TiO₂ NPs via phagocytosis, macropinocytosis, and clathrin-dependent endocytosis. Similarly, Ta NPs were internalized through phagocytosis (Figures 4(c) and 4(d)). However, macropinocytosis and clathrin- and caveolin-mediated endocytosis inhibitors did not significantly reduce Ta uptake, indicating the absence of these mechanisms. In summary, the active internalization of TiO₂ and Ta NPs were dominated by phagocytosis. TiO₂ NP uptake also involved macropinocytosis as well as clathrin-mediated endocytosis, but to less extent. Caveolae-mediated endocytosis seems not to be involved in the uptake of both particles.

3.5. Ta NPs Trigger Less ROS Production than TiO₂ NPs

NP-induced oxidative stress contributes to nanopathology [31]. In this study, the overall intracellular ROS elevation after NP challenge was examined using the probe 2,7-dichlorodihydrofluorescein diacetate (DCFH-DA). In our setup, as shown in Figure 5(a), TiO₂ NPs dose-dependently induced robust intracellular ROS generation at different time points. Comparison of these data showed that the majority of ROS was produced within the first hour after NP treatment. Notably, a reduction of endogenous ROS production was observed at 24 hours. This may result due to a decrease in cell viability (Figure 3(a)) at this time point. In contrast, Ta NPs induced negligible intracellular ROS elevation at different concentrations and incubation periods (Figure 5(b)). These results indicated that, compared to TiO₂ NPs, Ta NPs are “inert” in generating ROS.

(a)

(b)

3.6. Ta NPs Exert Less Proinflammatory Activity than TiO₂ NPs In Vitro

The wear particle-induced inflammatory response, mainly driven by macrophages, underlies the pathology of periprosthetic osteolysis and aseptic loosening [32]. Among all the proinflammatory mediators, TNFα and IL-1β are the primary initiators and significant mediators of the wear particle-induced inflammatory cascade. Therefore, we investigated the proinflammatory effect of TiO₂ and Ta NPs by evaluating their induction of TNFα and IL-1β with or without LPS priming.

As shown in Figure 6, the production of TNFα is only weakly stimulated by TiO₂ NPs alone (Figure 6(a)), whereas, in LPS-primed macrophages, TNFα release was markedly increased (Figure 6(b)). Further, simultaneous exposure of macrophages to TiO₂ NPs and LPS dose-dependently enhanced TNFα production (Figure 6(b)), which is well beyond the levels observed with TiO₂ NPs or LPS prime alone. Notably, TiO₂ NPs at low concentration (100μg/mL) induced significantly more TNFα production than Ta NPs at high concentration (500 μg/mL) in LPS-primed macrophages. This suggests that TiO₂ NPs synergized with LPS to stimulate the production of TNFα. Whereas, Ta NPs did not exert such synergistic effect (Figure 6(b)).

(a)

(b)

(c)

(d)

Figure 6

Proinflammatory potential of TiO₂ and Ta NPs on THP-1-derived macrophages. THP-1-derived macrophages were primed with 200 ng/mL LPS for 3 h, washed to remove the LPS, and then incubated with TiO₂ or Ta NPs using the indicated doses for up to 24 h. Release of (a, b) TNFα and (c, d) IL-1β were measured by ELISA. THP-1-derived macrophages without LPS stimulation were used as controls. indicates significant differences of different time points of the TiO₂ NP group compared to the TiO₂ NP 1 h group (, , and ). # indicates significant differences compared to the TiO₂ NP (100 μg/mL) group at 24 h (). § indicates significant LPS-mediated TNFα release compared to the untreated group ().

Similar to TNFα, little IL-1β secretion was detected in macrophages challenged with Ta NPs alone up to 24 hours. TiO₂ NPs (500 μg/mL) stimulated a significantly higher IL-1β level than Ta NPs in unprimed macrophages, starting at 3h (Figure 6(c)). After LPS priming, much higher IL-1β levels were detected in TiO₂-treated macrophages. TiO₂ NPs further elevated IL-1β release in a time- and dose-dependent manner (Figure 6(d)), higher than LPS or TiO₂ NPs alone. In contrast to the TNFα result, the Ta NP groups stimulated a negligible IL-1β increase after LPS priming (Figure 6(d)) compared to the untreated group. This indicated that the IL-1β level was not entirely dependent on LPS. In summary, these results suggest that LPS aggravates inflammation in macrophages. Also, TiO₂ NPs synergized with the LPS effect to increase the production of TNFα and IL-1β while Ta NPs did not. Thus, TiO₂ NPs possess a more substantial proinflammatory effect than Ta NPs.

3.7. Scavenging of ROS Attenuates TiO₂-Induced Cell Death and Proinflammatory Cytokine Release

Intracellular ROS are key effectors in signal transduction and are proposed to be associated with cell death and inflammation. ROS generation has been proven crucial for NP-induced NLRP3 inflammasome activation and subsequent IL-1β release [33, 34]. Therefore, we applied antioxidant NAC to prove the effect of ROS on TiO₂ NP-induced cell death and IL-1β release. NAC is a potent thiol-containing antioxidant that can act as a precursor of glutathione (GSH) and can also directly scavenge free radicals (e.g., H₂O₂ and OH^-) [35]. As shown in Figures 7(a) and 7(b), the fluorescence intensity was lower in NAC-treated cells in comparison to cells treated with TiO₂ NPs alone at 6 and 24h, indicating that NAC successfully antagonized ROS accumulation elicited by TiO₂ NPs in macrophages. Moreover, NAC treatment significantly mitigated cell death (Figure 6(c)) and potently blocked IL-1β release induced by TiO₂ NPs (Figure 6(d)) after LPS prime. These results indicated that ROS inhibition by NAC could rescue TiO₂ NP-induced nanotoxicity and mitigate IL-1β production in macrophages.

(a)

(b)

(c)

(d)

Figure 7

Protective role of ROS scavenger (NAC) on TiO₂ NP-induced cell death and IL-1β release. LPS-primed macrophages were preincubated for 30min with/without NAC (5mM), and then cotreated with TiO₂ NPs at the indicated doses for 6 and 24h. (a) Following exposure, cells were incubated with DCFH-DA (20μM) for 30 min at 37°C, and ROS production was detected by fluorescence microscopy (20x). Scale bar: 50μm. (b) Relative quantification of ROS generation (fold change). The protective role of NAC on (c) cell viability and release of (d) IL-1β were measured by CCK-8 and ELISA, respectively. Data are presented as of three identical experiments performed in three replicates. indicates significant difference as compared to the control (, , and ); § indicates significant inhibitory effect of NAC on cell death and proinflammatory cytokine generation (, , and ).

4. Discussion

Ta-based implants have been widely used in primary and revision TJA. Nevertheless, knowledge about the possible effect of their wear products on peri-implant cells remains limited to date. Therefore, understanding the local cellular responses to nanoscale orthopedic wear particles will provide a new area for comprehension of aseptic loosening and offers new scientifically based recommendations to better design suitable prosthetic interfaces and scaffolds. To the best of our knowledge, the present paper is the first in vitro analysis investigating Ta NPs and TiO₂ metallic NPs side by side in terms of their biological responses on macrophages. We provide scientific evidence that Ta NPs are inert, nontoxic, and noninflammatory NPs in vitro. The results of this study offer novel evidence-based insights to further substantiate the clinical application of Ta-based implants [36, 37].

We found a slight but significant increase in macrophage viability in the presence of 20μg/mL Ta NPs at 1 and 3 days. Similar results were found in the study by Wang et al. and Kang et al. showing that Ta NPs promote the proliferation of mouse MC3T3-E1 osteoblasts at low concentration (less than 20 μg/mL) through the induction of autophagy [38, 39]. However, our CCK-8 and LDH results also demonstrated that Ta NPs, even when using higher concentrations (e.g., 50-500μg/mL) and longer incubation times (up to 7 days), still resulted in high cell viability, which ultimately supports their good biocompatibility. In contrast, TiO₂ NPs started to exhibit significant cytotoxicity at the 24-hour incubation time point. These aspects precisely show how important it is to fully characterize the cellular response of peri-implant cells to new implant materials and their resulting NPs. Therefore, the present study is of particular interest as it provides the first comparative analysis showing that Ta NPs induced less cytotoxicity in macrophages than NPs stemming from Ti implants.

Phagocytosis and endocytosis are responsible for the uptake and clearance of particles [27, 40]. However, to date, the mechanistic nature of TiO₂ and Ta NP internalization in human macrophages remains obscure. Our study demonstrated that active Ta and TiO₂ NP internalization by macrophages is mainly driven by phagocytosis. Further, TiO₂ internalization is also mediated, to a lesser extent, by clathrin-dependent endocytosis and micropinocytosis. These results are supported by previous studies, which have shown that TiO₂ particle internalization is mediated by phagocytosis and endocytosis in glial cells [28], H9c2 rat cardiomyoblasts [27], and rodent macrophages [41, 42]. The multiple uptake pathways of TiO₂ NPs may partially explain why they were internalized more efficiently and why they induce more robust cytotoxicity, oxidative stress, and inflammatory cytokines compared to Ta NPs under the same conditions.

Increased bone resorption due to chronic inflammatory responses from wear particle-challenged macrophages underlies the pathogenesis of periprosthetic osteolysis [21]. TNFα is a master cytokine during inflammation and a potent inducer of other proinflammatory chemokines and cytokines. When focussing on inflammatory cytokines, the Ta-based surface seems to exert an anti-inflammatory effect compared to the Ti-based surface [43], suggesting that Ta substrates are more biologically inert and may provide a more favorable environment when applied as biomaterial. However, other studies reported that Ta-based surfaces could be more inflammatory than Ti-based [44] surfaces. This discrepancy may be attributed to the difference in surface elemental composition, modification methods, and culturing model (in vitro, in vivo, and ex vivo).

Our results demonstrated that Ta and TiO₂ NPs induced slight TNFα production without LPS priming. After exposure to LPS, which mimicked the situation of a low-grade infection in addition to the presence of wear particles, TNFα secretion increased over time in both NP groups. This is mainly because LPS can stimulate TNFα production through binding to Toll-like receptor-4 and subsequent activation of transcription factor NF-κB. It is important to note that the TNF level elevation over time in the LPS plus Ta NP group is insignificant compared to that of the LPS-only group. In contrast, TiO₂ NPs act synergistically with LPS and further elevate TNFα production. This synergistic effect directly leads to a significantly higher amount of TNFα in the TiO₂ NP group (100μg/mL) compared to the Ta NP group (100 and 500μg/mL), indicating that, in the form of nanoscale particles, Ta is less proinflammatory than Ti particles.

IL-1β is considered an essential proinflammatory mediator driving osteolysis at the bone-implant interface. Recent studies demonstrated that orthopedic wear particles mediate IL-1β release via activation of the NLRP3 inflammasome [45, 46], whose activation is a two-step process requiring both priming (e.g., bacterial LPS) and activation signals (e.g., nigericin, silica crystal, and wear particles). Supporting these data, dramatic elevation of IL-1β secretion was only observed after LPS priming and TiO₂ NPs. This indicated that both LPS priming and wear particles are required to license NLRP3 inflammasome activation [47]. Infection (in our case simulated by LPS) thus could be a potent inducer of inflammation, dramatically amplifying wear particle-induced inflammation and, therefore, could be a risk factor for implant loosening. The current results are in line with previous data which showed that LPS contributes to the biological activity of wear particles by increasing the proinflammatory cytokine production in macrophages [46, 48]. It is important to note that 500 μg/mL Ta NPs induced similar SSC elevation to that of 100 μg/mL TiO₂ NPs at 6 hours. However, Ta NPs stimulated almost no elevation of IL-1β in the supernatant over time, even after priming with LPS. This, again, supported the noninflammatory property of Ta NPs compared to TiO₂ NPs. It also suggests that, in the context of peri-implant infection, Ta-based implants may help limit the peri-implant inflammation, or could be a proper choice in revision surgery due to periprosthetic joint infection (PJI).

Interestingly, TiO₂ NPs alone induced a low but significant elevation of IL-1β over time. Given that all our particle samples were endotoxin-free, this effect may be due to other priming signals, such as TNFα [49] (Figure 6(a)). This fits the clinical picture in which increased values of IL-1β are detected together with TNFα in chronic low-grade peri-implant inflammation without any sign of infection.

Oxidative stress has been proposed to play a role in nanotoxicology and inflammatory reactions [31, 50]. Previous studies have revealed that, compared to Ti substrates, Ta substrates demonstrate lower ROS generation in osteoblasts and bone marrow stromal cells and, therefore, exhibit better cellular viability and osteoinductivity [23, 51]. In our study, we found that TiO₂ NPs induced robust ROS elevation while Ta NPs induced negligible amounts of ROS. This distinct difference in ROS-generating potential could be mainly attributed to the difference in particle type. Nevertheless, we cannot exclude that there are other potential influential factors, e.g., uptake efficiency, size, morphology, and oxidation extent. Furthermore, TiO₂ NPs demonstrated higher cytotoxicity and induced higher inflammatory cytokines than Ta NPs. Thus, it is feasible to speculate that the difference in cytotoxicity and IL-1β release is due to differences in NPs’ oxidative potential. We further proved this notion using NAC, a general ROS scavenger. Our study demonstrated that scavenging ROS with NAC abrogated TiO₂ NP-induced ROS production in macrophages. Furthermore, NAC mitigated TiO₂ NP-induced cell death and abrogated IL-1β release. Similar results were found in previous studies in which ROS suppression by NAC protected cells from cell death [52, 53] and IL-1β release [54–57] in response to ROS-generating NPs. This further proved that ROS depression can mitigate NP-induced cell death and IL-1β production and, therefore, may alleviate peri-implant tissue and inflammation. Although NAC has been successfully applied in previous studies as a ROS scavenger, it has multiple effects on cells [58, 59], which complicates the interpretation of the results. More specific ROS inhibitors are needed in the future to identify the ROS source. Collectively, the differences in inducing oxidative stress could explain why Ta NPs are relatively inert opposed to promoting cell death and inflammation as previously described for TiO₂, or other widely used NPs such as silica NPs [60]. Furthermore, targeting ROS may serve as a therapeutic way to mitigate wear particle-induced chronic inflammation and prosthetic loosening. However, the exact source of ROS, e.g., mitochondrial and NADPH oxidase, and their relative contribution to NP-induced inflammation, need further characterization.

5. Conclusions

For the first time in this study, we examined macrophages’ cellular response to nanoscale Ta and Ti particles in vitro. We found that Ta, in the form of nanoscale particles, was “bioinert” and induced less cytotoxicity, ROS production, and inflammatory response compared to TiO₂ NPs. Thus, when applied as TJA biomaterials, Ta-based implants may provide a more favorable peri-implant biological environment and less potential to contribute to aseptic loosening than Ti implants. Considering that multiple biomaterials have been applied in the TJA field, comparing Ta particles with additional other particle types (e.g., polyethylene, cobalt, and chromium) should be included in future studies to assess the value of switching from conventional implants to Ta-based implants.

Data Availability

The data used to support the findings of this study are available from the corresponding authors upon request.

Conflicts of Interest

The authors declare that there is no conflict of interest regarding the publication of this article.

Authors’ Contributions

Koroush Kabir and Frank A. Schildberg contributed equally to this work.

Acknowledgments

We appreciate the technical assistance from Ms. Cäcilia Hilgers, Mr. Werner Masson, and Mr. Knut Wichterich. Furthermore, we would like to acknowledge the assistance of the Flow Cytometry Core Facility at the Institute of Experimental Immunology, Medical Faculty at the University of Bonn. We would also like to acknowledge the assistance of the Microscopy Core Facility of the Medical Faculty within the Bonn Technology Campus Life Sciences, University of Bonn as well as the EDX-Facility at the Department of Horticultural Sciences, Faculty of Agriculture, University of Bonn. Furthermore, we thank Dr. Shu Chen for her support and help in this project. We thank the China Scholarship Council (CSC) for the financial support of this work.

Supplementary Materials

Supplementary Table 1: hydrodynamic radius measured by DLS. TiO₂ and Ta nanoparticles (NPs) were dispersed in ddH₂O, PBS, RPMI 1640, and RPMI 1640 containing 10% FBS at 250 μg/mL. Hydrodynamic radius (nm) was determined by DLS, and data from major peaks were presented. Supplementary Figure 1: endotoxin contamination of TiO₂ and Ta NPs. Quantitative evaluation of endotoxin contamination was determined by an LAL endotoxin assay kit. Data were representative of three independent experiments. The endotoxin level was calculated according to the standard curve. n.d.: not detectable. Supplementary Figure 2: spectral intensities of the Ta (a) and TiO₂ (b) samples observed in the energy-dispersive X-ray (EDX) analysis system. The spectra were analyzed in high vacuum (accelerating voltage: 20kV; spot size: 5.5). No contamination of other elements were observed. Supplementary Figure 3: cytotoxic effects of TiO₂ and Ta NPs on macrophages from 1 day to 7 days. (a, b) Cell viability was determined by CCK-8 assay at indicated time points. (c, d) Lactate dehydrogenase (LDH) leakage was evaluated by LDH assay after 24h. Viability and LDH release are normalized and expressed as as percentage of untreated cells of three independent experiments (, , and ). n.d.: not detectable. Nc: nontreated control. Supplementary Figure 4: cytotoxic effects of inhibitors on macrophages. Macrophages were incubated with different concentrations of uptake inhibitors, and cell viability was evaluated by CCK-8 assay. Viability is normalized and expressed as as the percentage of untreated cells of three independent experiments. , compared with control. (Supplementary Materials)

References

O. N. Schipper, S. L. Haddad, P. Pytel, and Y. Zhou, “Histological analysis of early osteolysis in total ankle arthroplasty,” Foot & Ankle International, vol. 38, no. 4, pp. 351–359, 2016.
View at: Publisher Site | Google Scholar
T. Schmalzried, M. Jasty, and W. H. Harris, “Periprosthetic bone loss in total hip arthroplasty: polyethylene wear debris and the concept of the effective joint space,” The Journal of bone and joint surgery, vol. 74, no. 6, pp. 849–863, 1992.
View at: Publisher Site | Google Scholar
K. Hirakawa, T. W. Bauer, B. N. Stulberg, and A. H. Wilde, “Comparison and quantitation of wear debris of failed total hip and total knee arthroplasty,” Journal of Biomedical Materials Research, vol. 31, no. 2, pp. 257–263, 1996.
View at: Publisher Site | Google Scholar
K. J. Margevicius, T. W. Bauer, J. T. McMahon, S. A. Brown, and K. Merritt, “Isolation and characterization of debris in membranes around total joint prostheses,” JBJS, vol. 76, no. 11, pp. 1664–1675, 1994.
View at: Publisher Site | Google Scholar
D. J. Hall, R. Pourzal, J. J. Jacobs, and R. M. Urban, “Metal wear particles in hematopoietic marrow of the axial skeleton in patients with prior revision for mechanical failure of a hip or knee arthroplasty,” Journal of Biomedical Materials Research Part B: Applied Biomaterials, vol. 107, no. 6, pp. 1930–1936, 2018.
View at: Publisher Site | Google Scholar
I. Polyzois, D. Nikolopoulos, I. Michos, E. Patsouris, and S. Theocharis, “Local and systemic toxicity of nanoscale debris particles in total hip arthroplasty,” Journal of Applied Toxicology, vol. 32, no. 4, pp. 255–269, 2012.
View at: Publisher Site | Google Scholar
A. C. Paulus, K. Ebinger, X. Cheng et al., “Local biological reactions and pseudotumor-like tissue formation in relation to metal wear in a murine in vivo model,” BioMed Research International, vol. 2019, 10 pages, 2019.
View at: Publisher Site | Google Scholar
D. R. Bijukumar, A. Segu, J. C. Souza et al., “Systemic and local toxicity of metal debris released from hip prostheses: a review of experimental approaches,” Nanomedicine: Nanotechnology, Biology and Medicine, vol. 14, no. 3, pp. 951–963, 2018.
View at: Publisher Site | Google Scholar
N. A. Beckmann, R. G. Bitsch, M. Schonhoff, K.-A. Siebenrock, M. Schwarze, and S. Jaeger, “Comparison of the primary stability of porous tantalum and titanium acetabular revision constructs,” Materials, vol. 13, no. 7, p. 1783, 2020.
View at: Publisher Site | Google Scholar
H. Abdelaziz, R. Jaramillo, T. Gehrke, M. Ohlmeier, and M. Citak, “Clinical survivorship of aseptic revision total knee arthroplasty using hinged knees and tantalum cones at minimum 10-year follow-up,” The Journal of Arthroplasty, vol. 34, no. 12, pp. 3018–3022, 2019.
View at: Publisher Site | Google Scholar
M. T. Houdek, P. C. Ferguson, M. P. Abdel et al., “Comparison of porous tantalum acetabular implants and Harrington reconstruction for metastatic disease of the acetabulum,” Journal of Bone and Joint Surgery, vol. 102, no. 14, pp. 1239–1247, 2020.
View at: Publisher Site | Google Scholar
G. Mohandas, N. Oskolkov, M. T. McMahon, P. Walczak, and M. Janowski, “Porous tantalum and tantalum oxide nanoparticles for regenerative medicine,” Acta Neurobiologiae Experimentalis, vol. 74, no. 2, pp. 188–196, 2014.
View at: Google Scholar
M. Stiehler, M. Lind, T. Mygind et al., “Morphology, proliferation, and osteogenic differentiation of mesenchymal stem cells cultured on titanium, tantalum, and chromium surfaces,” Journal of Biomedical Materials Research Part A, vol. 86A, no. 2, pp. 448–458, 2008.
View at: Publisher Site | Google Scholar
Q. Wang, H. Zhang, Q. Li et al., “Biocompatibility and osteogenic properties of porous tantalum,” Experimental and Therapeutic Medicine, vol. 9, no. 3, pp. 780–786, 2015.
View at: Publisher Site | Google Scholar
R. M. Meneghini, C. Meyer, C. A. Buckley, A. D. Hanssen, and D. G. Lewallen, “Mechanical stability of novel highly porous metal acetabular components in revision total hip arthroplasty,” The Journal of Arthroplasty, vol. 25, no. 3, pp. 337–341, 2010.
View at: Publisher Site | Google Scholar
D. R. Jenkins, A. N. Odland, R. J. Sierra, A. D. Hanssen, and D. G. Lewallen, “Minimum five-year outcomes with porous tantalum acetabular cup and augment construct in complex revision total hip arthroplasty,” The Journal of Bone and Joint Surgery, vol. 99, no. 10, p. e49, 2017.
View at: Publisher Site | Google Scholar
J. Schoon, S. Geißler, J. Traeger et al., “Multi-elemental nanoparticle exposure after tantalum component failure in hip arthroplasty: in-depth analysis of a single case,” Nanomedicine: Nanotechnology, Biology and Medicine, vol. 13, no. 8, pp. 2415–2423, 2017.
View at: Publisher Site | Google Scholar
G. C. Babis, N. A. Stavropoulos, G. Sasalos, M. Ochsenkuehn-Petropoulou, and P. Megas, “Metallosis and elevated serum levels of tantalum following failed revision hip arthroplasty—a case report,” Acta Orthopaedica, vol. 85, no. 6, pp. 677–680, 2014.
View at: Publisher Site | Google Scholar
A. Brüggemann, H. Mallmin, M. Bengtsson, and N. P. Hailer, “Safety of use of tantalum in total hip arthroplasty,” JBJS, vol. 102, no. 5, pp. 368–374, 2020.
View at: Publisher Site | Google Scholar
E. Ingham and J. Fisher, “The role of macrophages in osteolysis of total joint replacement,” Biomaterials, vol. 26, no. 11, pp. 1271–1286, 2005.
View at: Publisher Site | Google Scholar
C. Nich, Y. Takakubo, J. Pajarinen et al., “Macrophages—key cells in the response to wear debris from joint replacements,” Journal of biomedical materials research Part A, vol. 101, no. 10, pp. 3033–3045, 2013.
View at: Publisher Site | Google Scholar
N. J. Hallab and J. J. Jacobs, “Chemokines associated with pathologic responses to orthopedic implant debris,” Frontiers in Endocrinology, vol. 8, p. 5, 2017.
View at: Publisher Site | Google Scholar
M. Lu, P. Wu, X. Guo, L. Yin, H. Cao, and D. Zou, “Osteoinductive effects of tantalum and titanium on bone mesenchymal stromal cells and bone formation in ovariectomized rats,” European Review for Medical and Pharmacological Sciences, vol. 22, no. 21, pp. 7087–7104, 2018.
View at: Publisher Site | Google Scholar
X. Dou, X. Wei, G. Liu et al., “Effect of porous tantalum on promoting the osteogenic differentiation of bone marrow mesenchymal stem cells in vitro through the MAPK/ERK signal pathway,” Journal of Orthopaedic Translation, vol. 19, pp. 81–93, 2019.
View at: Publisher Site | Google Scholar
L.-Y. Shi, A. Wang, F.-Z. Zang, J.-X. Wang, X.-W. Pan, and H.-J. Chen, “Tantalum-coated pedicle screws enhance implant integration,” Colloids and Surfaces B: Biointerfaces, vol. 160, pp. 22–32, 2017.
View at: Publisher Site | Google Scholar
H. Ding, Z. Zhu, T. Tang, D. Yu, B. Yu, and K. Dai, “Comparison of the cytotoxic and inflammatory responses of titanium particles with different methods for endotoxin removal in RAW264.7 macrophages,” Journal of Materials Science: Materials in Medicine, vol. 23, no. 4, pp. 1055–1062, 2012.
View at: Publisher Site | Google Scholar
E. Huerta-García, M. D. P. Ramos-Godinez, A. López-Saavedra et al., “Internalization of titanium dioxide nanoparticles is mediated by actin-dependent reorganization and clathrin-and dynamin-mediated endocytosis in H9c2 rat cardiomyoblasts,” Chemical Research in Toxicology, vol. 32, no. 4, pp. 578–588, 2019.
View at: Publisher Site | Google Scholar
E. Huerta-García, S. G. Márquez-Ramírez, M. . P. Ramos-Godinez et al., “Internalization of titanium dioxide nanoparticles by glial cells is given at short times and is mainly mediated by actin reorganization-dependent endocytosis,” Neurotoxicology, vol. 51, pp. 27–37, 2015.
View at: Publisher Site | Google Scholar
J. Linares, M. C. Matesanz, M. Vila et al., “Endocytic mechanisms of graphene oxide nanosheets in osteoblasts, hepatocytes and macrophages,” ACS Applied Materials & Interfaces, vol. 6, no. 16, pp. 13697–13706, 2014.
View at: Publisher Site | Google Scholar
J. Park, M. K. Ha, N. Yang, and T. H. Yoon, “Flow cytometry-based quantification of cellular Au nanoparticles,” Analytical Chemistry, vol. 89, no. 4, pp. 2449–2456, 2017.
View at: Publisher Site | Google Scholar
P. P. Fu, Q. Xia, H.-M. Hwang, P. C. Ray, and H. Yu, “Mechanisms of nanotoxicity: generation of reactive oxygen species,” Journal of Food and Drug Analysis, vol. 22, no. 1, pp. 64–75, 2014.
View at: Publisher Site | Google Scholar
S. B. Goodman and J. Gallo, “Periprosthetic osteolysis: mechanisms, prevention and treatment,” Journal of Clinical Medicine, vol. 8, no. 12, p. 2091, 2019.
View at: Publisher Site | Google Scholar
S. Feng, Z. Zhang, Y. Mo et al., “Activation of NLRP3 inflammasome in hepatocytes after exposure to cobalt nanoparticles: the role of oxidative stress,” Toxicology In Vitro, vol. 69, p. 104967, 2020.
View at: Publisher Site | Google Scholar
M. Zhu, L. Du, R. Zhao et al., “Cell-penetrating nanoparticles activate the inflammasome to enhance antibody production by targeting microtubule-associated protein 1-light chain 3 for degradation,” ACS Nano, vol. 14, no. 3, pp. 3703–3717, 2020.
View at: Publisher Site | Google Scholar
N. Daems, S. Penninckx, I. Nelissen et al., “Gold nanoparticles affect the antioxidant status in selected normal human cells,” International Journal of Nanomedicine, vol. Volume 14, pp. 4991–5015, 2019.
View at: Publisher Site | Google Scholar
Z. Miao, P. Liu, Y. Wang et al., “PEGylated tantalum nanoparticles: a metallic photoacoustic contrast agent for multiwavelength imaging of tumors,” Small, vol. 15, no. 41, article 1903596, 2019.
View at: Publisher Site | Google Scholar
H. Zhu, X. Ji, H. Guan et al., “Tantalum nanoparticles reinforced polyetheretherketone shows enhanced bone formation,” Materials Science and Engineering: C, vol. 101, pp. 232–242, 2019.
View at: Publisher Site | Google Scholar
P. Wang, P. Qiao, H. Xing, R. Zhang, E. Lingling, and H. Liu, “Cytotoxicity, oxidative stress, and autophagy effects of tantalum nanoparticles on MC3T3-E1 mouse osteoblasts,” Journal of Nanoscience and Nanotechnology, vol. 20, no. 3, pp. 1417–1424, 2020.
View at: Publisher Site | Google Scholar
C. Kang, L. Wei, B. Song et al., “Involvement of autophagy in tantalum nanoparticle-induced osteoblast proliferation,” International Journal of Nanomedicine, vol. Volume 12, pp. 4323–4333, 2017.
View at: Publisher Site | Google Scholar
M. Geiser, “Update on macrophage clearance of inhaled micro- and nanoparticles,” Journal of Aerosol Medicine and Pulmonary Drug Delivery, vol. 23, no. 4, pp. 207–217, 2010.
View at: Publisher Site | Google Scholar
A. M. Scherbart, J. Langer, A. Bushmelev et al., “Contrasting macrophage activation by fine and ultrafine titanium dioxide particles is associated with different uptake mechanisms,” Particle and fibre toxicology, vol. 8, no. 1, p. 31, 2011.
View at: Publisher Site | Google Scholar
Q. Chen, N. Wang, M. Zhu et al., “TiO₂ nanoparticles cause mitochondrial dysfunction, activate inflammatory responses, and attenuate phagocytosis in macrophages: a proteomic and metabolomic insight,” Redox Biology, vol. 15, pp. 266–276, 2018.
View at: Publisher Site | Google Scholar
Q. Huang, X. Li, T. A. Elkhooly et al., “The osteogenic, inflammatory and osteo-immunomodulatory performances of biomedical Ti-Ta metal-metal composite with Ca- and Si-containing bioceramic coatings,” Colloids and Surfaces B: Biointerfaces, vol. 169, pp. 49–59, 2018.
View at: Publisher Site | Google Scholar
C. Yang, J. Li, C. Zhu et al., “Advanced antibacterial activity of biocompatible tantalum nanofilm via enhanced local innate immunity,” Acta Biomaterialia, vol. 89, pp. 403–418, 2019.
View at: Publisher Site | Google Scholar
L. Burton, D. Paget, N. B. Binder et al., “Orthopedic wear debris mediated inflammatory osteolysis is mediated in part by NALP3 inflammasome activation,” Journal of Orthopaedic Research, vol. 31, no. 1, pp. 73–80, 2013.
View at: Publisher Site | Google Scholar
E. Jämsen, J. Pajarinen, V.-P. Kouri et al., “Tumor necrosis factor primes and metal particles activate the NLRP3 inflammasome in human primary macrophages,” Acta Biomaterialia, vol. 108, pp. 347–357, 2020.
View at: Publisher Site | Google Scholar
G. W. Manzano, B. P. Fort, G. R. Dubyak, and E. M. Greenfield, “Wear particle-induced priming of the NLRP3 inflammasome depends on adherent pathogen-associated molecular patterns and their cognate Toll-like receptors: an in vitro study,” Clinical orthopaedics and related research, vol. 476, no. 12, pp. 2442–2453, 2018.
View at: Publisher Site | Google Scholar
E. M. Greenfield, M. A. Beidelschies, J. M. Tatro, V. M. Goldberg, and A. G. Hise, “Bacterial pathogen-associated molecular patterns stimulate biological activity of orthopaedic wear particles by activating cognate Toll-like receptors,” Journal of Biological Chemistry, vol. 285, no. 42, pp. 32378–32384, 2010.
View at: Publisher Site | Google Scholar
J. S. Bezbradica, R. C. Coll, and K. Schroder, “Sterile signals generate weaker and delayed macrophage NLRP3 inflammasome responses relative to microbial signals,” Cellular & Molecular Immunology, vol. 14, no. 1, pp. 118–126, 2017.
View at: Publisher Site | Google Scholar
P. Khanna, C. Ong, B. H. Bay, and G. H. Baeg, “Nanotoxicity: an interplay of oxidative stress, inflammation and cell death,” Nanomaterials, vol. 5, no. 3, pp. 1163–1180, 2015.
View at: Publisher Site | Google Scholar
L. Wang, X. Hu, X. Ma et al., “Promotion of osteointegration under diabetic conditions by tantalum coating-based surface modification on 3-dimensional printed porous titanium implants,” Colloids and Surfaces B: Biointerfaces, vol. 148, pp. 440–452, 2016.
View at: Publisher Site | Google Scholar
C.-Q. Luo, L. Xing, P.-F. Cui et al., “Curcumin-coordinated nanoparticles with improved stability for reactive oxygen species-responsive drug delivery in lung cancer therapy,” International Journal of Nanomedicine, vol. Volume 12, pp. 855–869, 2017.
View at: Publisher Site | Google Scholar
K.-I. Lee, C.-C. Su, K.-M. Fang, C.-C. Wu, C.-T. Wu, and Y.-W. Chen, “Ultrafine silicon dioxide nanoparticles cause lung epithelial cells apoptosis via oxidative stress-activated PI3K/Akt-mediated mitochondria-and endoplasmic reticulum stress-dependent signaling pathways,” Scientific Reports, vol. 10, no. 1, pp. 1–13, 2020.
View at: Publisher Site | Google Scholar
T. Morishige, Y. Yoshioka, A. Tanabe et al., “Titanium dioxide induces different levels of IL-1β production dependent on its particle characteristics through caspase-1 activation mediated by reactive oxygen species and cathepsin B,” Biochemical and Biophysical Research Communications, vol. 392, no. 2, pp. 160–165, 2010.
View at: Publisher Site | Google Scholar
T. Adachi, K. Takahara, J. Taneo, Y. Uchiyama, and K. Inaba, “Particle Size of Latex Beads Dictates IL-1β Production Mechanism,” PloS one, vol. 8, no. 7, p. e68499, 2013.
View at: Publisher Site | Google Scholar
H. Yao, Y. Zhang, L. Liu et al., “Inhibition of lanthanide nanocrystal-induced inflammasome activation in macrophages by a surface coating peptide through abrogation of ROS production and TRPM2-mediated Ca²⁺ influx,” Biomaterials, vol. 108, pp. 143–156, 2016.
View at: Publisher Site | Google Scholar
O. Lunov, T. Syrovets, C. Loos et al., “Amino-functionalized polystyrene nanoparticles activate the NLRP3 inflammasome in human macrophages,” ACS Nano, vol. 5, no. 12, pp. 9648–9657, 2011.
View at: Publisher Site | Google Scholar
X. Pan, X. Wu, D. Yan, C. Peng, C. Rao, and H. Yan, “Acrylamide-induced oxidative stress and inflammatory response are alleviated by N-acetylcysteine in PC12 cells: involvement of the crosstalk between Nrf2 and NF-κB pathways regulated by MAPKs,” Toxicology Letters, vol. 288, pp. 55–64, 2018.
View at: Publisher Site | Google Scholar
S. S. Karuppagounder, L. Alin, Y. Chen et al., “N-Acetylcysteine targets 5 lipoxygenase-derived, toxic lipids and can synergize with prostaglandin E2to inhibit ferroptosis and improve outcomes following hemorrhagic stroke in mice,” Ann Neurol, vol. 84, no. 6, pp. 854–872, 2018.
View at: Publisher Site | Google Scholar
S. Kim, J. Jang, H. Kim, H. Choi, K. Lee, and I.-H. Choi, “The effects of silica nanoparticles in macrophage cells,” Immune network, vol. 12, no. 6, pp. 296–300, 2012.
View at: Publisher Site | Google Scholar

Copyright

Copyright © 2020 Li Zhang et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

PDF Download Citation

Download other formats

Order printed copies

Views

1658

Downloads

987

Citations

Mediators of Inflammation

Mediators of Inflammation in Bone Physiology and Diseases

Investigation of Cytotoxicity, Oxidative Stress, and Inflammatory Responses of Tantalum Nanoparticles in THP-1-Derived Macrophages

Abstract

1. Introduction

2. Materials and Methods

2.1. Cell Culture and Differentiation

2.2. Particle Preparation

2.3. Characterization of Particles

2.4. Endotoxin Test

2.5. Cell Viability Assay

2.6. Lactate Dehydrogenase Release Assay

2.7. Measurement of Nanoparticle Uptake by Flow Cytometry

2.8. Bright-Field Microscopy

2.9. Measurement of Intracellular ROS Generation

2.10. Enzyme-Linked Immunosorbent Assay (ELISA)

2.11. Statistical Analysis

3. Results

3.1. Nanoparticle Characterization

3.2. Bright-Field Microscopy of THP-1-Derived Macrophages Exposed to TiO2 and Ta NPs

3.3. Analysis of the Cytotoxic Effect of TiO2 and Ta NPs in THP-1-Derived Macrophages

3.4. Cellular Uptake and Internalization Routes of TiO2 and Ta NPs

3.5. Ta NPs Trigger Less ROS Production than TiO2 NPs

3.6. Ta NPs Exert Less Proinflammatory Activity than TiO2 NPs In Vitro

3.7. Scavenging of ROS Attenuates TiO2-Induced Cell Death and Proinflammatory Cytokine Release

4. Discussion

5. Conclusions

Data Availability

Conflicts of Interest

Authors’ Contributions

Acknowledgments

Supplementary Materials

References

Copyright

3.2. Bright-Field Microscopy of THP-1-Derived Macrophages Exposed to TiO₂ and Ta NPs

3.3. Analysis of the Cytotoxic Effect of TiO₂ and Ta NPs in THP-1-Derived Macrophages

3.4. Cellular Uptake and Internalization Routes of TiO₂ and Ta NPs

3.5. Ta NPs Trigger Less ROS Production than TiO₂ NPs

3.6. Ta NPs Exert Less Proinflammatory Activity than TiO₂ NPs In Vitro

3.7. Scavenging of ROS Attenuates TiO₂-Induced Cell Death and Proinflammatory Cytokine Release