Table of Contents Author Guidelines Submit a Manuscript
Advances in Materials Science and Engineering
Volume 2014, Article ID 760584, 7 pages
http://dx.doi.org/10.1155/2014/760584
Research Article

Magnetic Behavior of Sintered NdFeB Magnets on a Long-Term Timescale

1Prizztech Oy, Magnet Technology Centre, 28100 Pori, Finland
2Tampere University of Technology, 28100 Pori, Finland
3Neorem Magnets Oy, 28400 Ulvila, Finland

Received 14 May 2013; Accepted 30 October 2013; Published 16 January 2014

Academic Editor: You Song

Copyright © 2014 Minna Haavisto et al. This is an open access article distributed under the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Linked References

  1. H. Sepehri-Amin, Y. Une, T. Ohkubo, K. Hono, and M. Sagawa, “Microstructure of fine-grained Nd-Fe-B sintered magnets with high coercivity,” Scripta Materialia, vol. 65, no. 5, pp. 396–399, 2011. View at Publisher · View at Google Scholar · View at Scopus
  2. R. Goto, M. Matsuura, S. Sugimoto et al., “Microstructure evaluation for Dy-free Nd-Fe-B sintered magnets with high coercivity,” Journal of Applied Physics, vol. 111, no. 7, Article ID 07A739, 2012. View at Google Scholar
  3. K. Morimoto, N. Katayama, H. Akamine et al., “Coercivity enhancement of anisotropic Dy-free NdFeB powders by conventional HDDR process,” Journal of Magnetism and Magnetic Materials, vol. 324, no. 22, pp. 3723–3726, 2012. View at Google Scholar
  4. H. Kim, J. Jin-Hur, B. Kim, and G. Kan, “Characteristic analysis of IPM type BLDC motor considering the demagnetization of PM by stator turn fault,” in 2nd IEEE Energy Conversion Congress and Exposition (ECCE '10), pp. 3063–3070, Atlanta, Ga, USA, September 2010. View at Publisher · View at Google Scholar · View at Scopus
  5. C. Kral, R. Sprangers, J. Waarma, A. Haumer, O. Winter, and E. Lomonova, “Modeling demagnetization effects in permanent magnet synchronous machines,” in 19th International Conference on Electrical Machines (ICEM '10), pp. 1–6, Rome, Italy, September 2010. View at Publisher · View at Google Scholar · View at Scopus
  6. J. D. McFarland and T. M. Jahns, “Investigation of the rotor demagnetization characteristics of interior PM synchronous machines during fault conditions,” in Energy Conversion Congress and Exposition (ECCE '12), pp. 4021–4028, Raleigh, NC, USA, September 2012.
  7. P. Guglielmi, B. Boazzo, E. Armando, G. Pellegrino, and A. Vagati, “Magnet minimization in IPM-PMASR motor design for wide speed range application,” in 3rd Annual IEEE Energy Conversion Congress and Exposition (ECCE '11), pp. 4201–4207, San Jose, Calif, USA, September 2011. View at Publisher · View at Google Scholar · View at Scopus
  8. H. Shin, T. H. Kim, and C. Kim, “A study on irreversible permanent magnet demagnetization in flux-reversal machines,” in International Conference on Electrical Machines and Systems (ICEMS '11), pp. 1–4, Beijing, China, August 2011. View at Publisher · View at Google Scholar · View at Scopus
  9. P. Zhou, D. Lin, Y. Xiao, N. Lambert, and M. A. Rahman, “Temperature-dependent demagnetization model of permanent magnets for finite element analysis,” IEEE Transactions on Magnetics, vol. 48, no. 2, pp. 1031–1034, 2012. View at Publisher · View at Google Scholar · View at Scopus
  10. J. Wang, W. Wang, K. Atallah et al., “A linear permanent-magnet motor for active vehicle suspension,” IEEE Transactions on Vehicular Technology, vol. 60, no. 1, pp. 55–63, 2011. View at Publisher · View at Google Scholar · View at Scopus
  11. D. J. Branagan, M. J. Kramer, Y. L. Tang, and R. W. McCallum, “Maximizing loop squareness by minimizing gradients in the microstructure,” Journal of Applied Physics, vol. 85, no. 8, pp. 5923–5925, 1999. View at Google Scholar · View at Scopus
  12. E. A. Périgo, H. Takiishi, C. C. Motta, and R. N. Faria, “Microstructure and squareness factor: a quantitative correlation in (Nd, Pr)FeB sintered magnets,” Journal of Applied Physics, vol. 102, no. 11, Article ID 113912, 4 pages, 2007. View at Publisher · View at Google Scholar · View at Scopus
  13. S. Ruoho, E. Dlala, and A. Arkkio, “Comparison of demagnetization models for finite-element analysis of permanent-magnet synchronous machines,” IEEE Transactions on Magnetics, vol. 43, no. 11, pp. 3964–3968, 2007. View at Publisher · View at Google Scholar · View at Scopus
  14. D. Givord, A. Lienard, P. Tenaud, and T. Viadieu, “Magnetic viscosity in Nd-Fe-B sintered magnets,” Journal of Magnetism and Magnetic Materials, vol. 67, no. 3, pp. L281–L285, 1987. View at Google Scholar · View at Scopus
  15. H. Nishio, “Magnetic aftereffect of Nd-Fe-B sintered magnets,” IEEE Transactions on Magnetics, vol. 24, no. 6, pp. 3188–3192, 1988. View at Publisher · View at Google Scholar · View at Scopus
  16. J. Shi, O. Yamada, H. Maruyama, M. Sagawa, and S. Hirosawa, “Magnetic aftereffect in rare earth-iron-boron magnets,” IEEE Transactions on Magnetics, vol. 23, no. 5, pp. 3122–3124, 1987. View at Google Scholar · View at Scopus
  17. M. Haavisto and M. Paju, “Temperature stability and flux losses over time in sintered NdFeB permanent magnets,” IEEE Transactions on Magnetics, vol. 45, no. 12, pp. 5277–5280, 2009. View at Publisher · View at Google Scholar · View at Scopus
  18. M. Haavisto, S. Tuominen, H. Kankaanpaa, and M. Paju, “Time dependence of demagnetization and flux losses occurring in sintered Nd-Fe-B permanent magnets,” IEEE Transactions on Magnetics, vol. 46, no. 9, pp. 3582–3584, 2010. View at Publisher · View at Google Scholar · View at Scopus
  19. M. Haavisto, H. Kankaanpää, and M. Paju, “Estimation of time-dependent polarization losses in sintered Nd-Fe-B permanent magnets,” IEEE Transactions on Magnetics, vol. 47, no. 1, pp. 170–174, 2011. View at Publisher · View at Google Scholar · View at Scopus
  20. B. D. Cullity and C. D. Graham, Introduction to Magnetic Materials, pp. 478–484, John Wiley & Sons, 2009.
  21. E. A. Perigo, H. Takiishi, C. C. Motta, and R. N. Faria, “On the squareness factor behavior of RE-FeB (RE = Nd or Pr) magnets above room temperature,” IEEE Transactions on Magnetics, vol. 45, no. 10, pp. 4431–4434, 2009. View at Publisher · View at Google Scholar · View at Scopus
  22. R. J. Parker, Advances in Permanent Magnetism, John Wiley & Sons, 1990.